Please help me, all powerful A4 B5 Guru

[Hex69]

I'll upload some pics later if this all works so we have a guide to fitting a fuel pump

I'm guessing that the fuel spurting all over the fuel sender is causing it to show a fault like a direct short (the whole thing is submerged in fuel)

Least i know I'm not short on fuel

Just don't be a fag-ash lil when doing it!!!

[BDT]

Just don't be a fag-ash lil when doing it!!!

Lucky enough, i had a 40 a day habit that i quit, well over a year ago.....

However, My A4 cut out 3 times this morning on the motorway, I figured I've risked it enough, and limped it hope via the side roads.

Never missed a beat on the side roads, yet on the motorway, it just cut out, no splutter or anything???

After my cup of tea, I'll run Vag-Com and see what it has to say.

I did notice that the temp gauge isn't reading anything anymore....

I'll investigate in a minute............... Could murder a ciggy right now

[BDT]

Here we go again........

17972/P1564/005476 - Throttle Actuator (J338): Under-Voltage during Basic Setting



17967/P1559/005465 - Throttle Body (J338): Fault in Basic Settings


16500/P0116/000278 - Engine Coolant Temp. Sensor (G62): Implausible Signal


I've replaced the G62 sensor already..

Crasher, is there a bleed valve/nipple for the cooling system? could i just have a air pocket causing it not to read the temp?

I've re-checked the plug, wires etc, and they are all fine......

[sbt]

hi. there is a bleed pipe at the left side of the battery that feeds the heater matrix you will notice a small hole in the top of the left pipe loosen the clip pull the hose forward till the hole is free from the pipe stub no need to remove the pipe run engine if you can and watch for air bubbles escaping

[BDT]

hi. there is a bleed pipe at the left side of the battery that feeds the heater matrix you will notice a small hole in the top of the left pipe loosen the clip pull the hose forward till the hole is free from the pipe stub no need to remove the pipe run engine if you can and watch for air bubbles escaping

Cheers mate,

now if the damn thing only would start again......

[BDT]

This is getting ridiculous now.

The new fuel pump from GSF has failed????

Just been on the phone, they told me they'll have me another one first thing in the morning, but I'm furious that a pump should fail having only covered less then 40 miles.


how long can i expect from the next one?

[Crasher]

What make was it?

[BDT]

What make was it?

Erstklassig