Notices
 
 

  

User Tag List

Thread: 3.0 tdi throttle valve issue

Page 1 of 3 123 LastLast
Results 1 to 10 of 22
  1. 3.0 tdi throttle valve issue 
    #1
    Join Date
    Dec 2008
    Location
    Stoke-on-Trent
    Posts
    59
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    5 Post(s)
    Hi

    hope someone can help.

    It all started last week where I was getting a pulsing from the engine, I knew it would be the gears on the throttle valve so i ordered a replacement set.

    Unfortunately the car decided otherwise and lost power on the M6, it didnt stall just lost all power.

    I stopped the engine and tried restarting, it fired but was only running at 400rpm, and no response from the throttle.

    Had it towed back and waited for replacement gears to arrive. I wipped off the throttle valve and as expected the gears were totalled chewed.

    New gears fitted and a clean whilst I had it apart, good movement from the gear operating the butterfly. Popped it back on and wonts start. Checked with my vcds and got this

    004203 - Throttle Valve
    P106B - 002 - Stuck or difficult to move - Intermittent

    I did scan it before initially took it off and had the same error.

    I unbolted the throttle valve and left it connected to the loom so I could see the butterfly doing its initialisation.

    It only opened about 25% and buzzed.

    Checked gears etc and no change.

    Bought a new throttle body and fitted it today, initialisation was correct on first key turn , fully closed and then open.

    bugger still wont start, cleared all the dtc's and rescanned but it not even attempting to start, got a battery booster connected to ensure its got full power.

    My normal mechanic (my cousin, cant get me in until mid next week) and ive been without a car all week. Its parked 15mins away in my caravan storage yard.

    Anyone got any tips ?

    thanks

    Simon
    2007 Avant 3.0 tdi Le Mans
     
    0 0 0
     

  2. Re: 3.0 tdi throttle valve issue 
    #2
    Join Date
    Jul 2008
    Location
    Lisburn
    Posts
    734
    Post Thanks / Like
    Mentioned
    4 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    15 Post(s)
    what codes did you get when you re-scanned? is there an output test for it in vcds?
    not even attempting? cant just see from here lol do you mean no response from key - engine wont crank, or cranks at low RPM......?
    Stewart
    2012 Q5 2.0D quattro S line Plus
    1986 coupe quattro (kv)
    1972 mini 1400 100BHP A series
    2016 F-Pace Portfolio X761 2.0D 180HP
     
    0 0 0
     

  3. Re: 3.0 tdi throttle valve issue 
    #3
    Join Date
    Dec 2008
    Location
    Stoke-on-Trent
    Posts
    59
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    5 Post(s)
    cant see any output test for it at all and I think the calibrations Ive seen are all for petrol versions

    engine cranks fine, just wont start

    not always but sometimes the same code comes back as in first thread
    2007 Avant 3.0 tdi Le Mans
     
    0 0 0
     

  4. Re: 3.0 tdi throttle valve issue 
    #4
    Join Date
    Jul 2008
    Location
    Lisburn
    Posts
    734
    Post Thanks / Like
    Mentioned
    4 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    15 Post(s)
    did you check ross tech website it could give some direction. Are all the electrical connections in good order, a bad one could mean its not getting enough juice to fully function.
    Stewart
    2012 Q5 2.0D quattro S line Plus
    1986 coupe quattro (kv)
    1972 mini 1400 100BHP A series
    2016 F-Pace Portfolio X761 2.0D 180HP
     
    0 0 0
     

  5. Re: 3.0 tdi throttle valve issue 
    #5
    Join Date
    Dec 2008
    Location
    Stoke-on-Trent
    Posts
    59
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    5 Post(s)
    the initial movement of the butterfly valve looks correct, ie as soon as you turn the ignition on it does a full close and back to open
    2007 Avant 3.0 tdi Le Mans
     
    0 0 0
     

  6. Re: 3.0 tdi throttle valve issue 
    #6
    Join Date
    Dec 2008
    Location
    Stoke-on-Trent
    Posts
    59
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    5 Post(s)
    Ive found this

    Ill have a walk done an d try it


    Special Notes

    • When found on 3.0l CR-TDI (i.e. BKS/BUG) or 4.2l CR-TDI (BVN), the Learning Values have to be cleared after replacing the Throttle Body Control Module.
      • DO NOT CLEAR LEARNED VALUES IF YOU HAVE NOT REPLACED THE THROTTLE BODY CONTROL MODULE! Otherwise the proper values are being cleared and incorrect values are being learned.

    [Select]
    [01 - Engine] (for Bank 1/J388) or [11 - Engine 2] (for Bank 2/J544)

    [Coding-II - 11]


    • Enable the Learning Procedure by Entering 10021.

    [Do It!]
    [Done, Go Back]
    [Close Controller, Go Back - 06]


    • Switch the Ignition OFF.
    • Switch the Ignition ON for 1 Second, then turn it OFF immediately.
    • Wait at least 30 Seconds, then switch the Ignition ON again.
    • Now Check if all remaining fault codes can be cleared.
    2007 Avant 3.0 tdi Le Mans
     
    0 0 0
     

  7. Re: 3.0 tdi throttle valve issue 
    #7
    Join Date
    Dec 2008
    Location
    Stoke-on-Trent
    Posts
    59
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    5 Post(s)
    well ive tried that and no joy

    scan only shows issues with glow plugs which ive had for ages

    found a throttle body test and that seems to work fine

    Im baffled !!!!!!!
    2007 Avant 3.0 tdi Le Mans
     
    0 0 0
     

  8. Re: 3.0 tdi throttle valve issue 
    #8
    Join Date
    Dec 2008
    Location
    Stoke-on-Trent
    Posts
    59
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    5 Post(s)
    If it was an immobiliser issue would that log up in vcds?

    or fuel supply problem?
    2007 Avant 3.0 tdi Le Mans
     
    0 0 0
     

  9. Re: 3.0 tdi throttle valve issue 
    #9
    Join Date
    Dec 2007
    Location
    Dudley, West Midlands
    Posts
    581
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    43 Post(s)
    I replaced mine with a new replacement unit i had no issues it just worked, i did not replace gears i swapped the throttle body.


    Sent from my iPhone using Tapatalk
    Regards Dean Warren. VCDS owner/user
    A6 C7 3.0 BiTDi Quattro Avant 2012 S-Line Tech pack tour Pack ACC Blind spot folding mirrors Sold
    S6 C8 3.0 TDI Quattro Avant 2021 360 Camera Bose Extended leather.
     
    0 0 0
     

  10. Re: 3.0 tdi throttle valve issue 
    #10
    Join Date
    Dec 2008
    Location
    Stoke-on-Trent
    Posts
    59
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    5 Post(s)
    Yes I bought a brand new throttle body this morning and have that fitted now
    gave up on the old one, I think there was a problem with it beyond the stripped gears
    2007 Avant 3.0 tdi Le Mans
     
    0 0 0
     

Page 1 of 3 123 LastLast

Similar Threads

  1. How To How I fixed my Audi A6 throttle issue with "Throttle Reset OBD2" ELM327
    By MrMikeR in forum Audi A6 - C6 Forum - 2005 - 2010
    Replies: 3
    Last Post: 27-04-2022, 04:39 PM
  2. How To How I fixed my Audi A6 throttle issue with "Throttle Reset OBD2" ELM327
    By MrMikeR in forum Chat - Completely Off Topic
    Replies: 1
    Last Post: 01-03-2021, 01:33 AM
  3. Throttle Valve.
    By fmc51 in forum Audi A6 - C6 Forum - 2005 - 2010
    Replies: 7
    Last Post: 29-04-2014, 02:27 PM
  4. EGR Valve/Throttle Valve, where is Fuse F8??
    By robtuke in forum Audi A3 - 8P - 2004 - 2012
    Replies: 3
    Last Post: 12-11-2013, 07:43 AM
  5. Throttle valve/actuator issue
    By staffop1 in forum VCDS - Help Requests
    Replies: 0
    Last Post: 01-12-2010, 11:57 PM
Bookmarks
Bookmarks
Posting Permissions
  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  


 



  


Disclaimer: VW Audi Forum is an "independant enthusiast website", administered in line with guidelines supplied by VAG in the UK, and is in no way related to any of the Worldwide Volkswagen,Audi,Seat,Skoda,Bentley,Bugatti,Porsche or Lamborghini group of Companies. For official up to date information on any of there vehicles, please visit the official websites. Any comments made throughout this website, are the views of the respective poster, and in no way represent the views of the VW Audi Forum Administration, or the worldwide Volkswagen & Audi Group of companies.


VW Audi Forum do not vet and are not responsible for any information which is posted in this forum. All content is viewed and used by you at your own risk and we do not warrant the accuracy or reliability of any of the information.


Copyright: Certain "words", "phrases" and "Images" used on this website by the Administration are "Copyright" of Volkswagen GB, Volkswagen AG (Germany), Audi GB, Audi AG (Germany), Volkswagen Motorsport GB, Volkswagen Motorsport AG (Germany), Audi Motorsport AG (Germany), Volkswagen Racing GB, Bentley, Bugatti, Porsche and Lamborghini. No image can be replicated by anyone WITHOUT the relevant Companies written permission.


All trademarks and copyrights remain property of their respective owners.

No part of the VW Audi Forum website or forum may be reproduced without written permission from the site administration


PLEASE NOTE - PERSONAL ABUSE, ABUSE AGAINST THIS OR ANY OTHER WEBSITE OR ANY COMPANY WILL NOT BE TOLERATED. OFFENDERS WILL BE MODERATED OR EVEN BANNED.


This website and forum are best viewed at a minimum resolution of 1024 by 768.



  



- VW AUDI Forum - The #1 Volkswagen (VW) Group Forum - Volkswagen (VW) - Audi - Seat - Skoda - Bentley - Bugatti - Lamborghini - Porsche - Scania - MAN - Ducatti - VW Audi Forum -


- www.vwaudiforum.co.uk - www.vwaudiforum.co.uk -