Notices
 
 

  

User Tag List

Thread: Allroad Air Suspension Compressor strip & repair

Page 46 of 46 FirstFirst ... 36444546
Results 451 to 458 of 458
  1. Re: Allroad Air Suspension Compressor strip & repair 
    Join Date
    Apr 2010
    Location
    blackburn
    Posts
    8
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    0 Post(s)
    I'm pretty sure the kit came from you. I saw your card somewhere an eBay one?
     
    0 0 0
     

  2. Re: Allroad Air Suspension Compressor strip & repair 
    Join Date
    Aug 2020
    Location
    Chester
    Posts
    3
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    0 Post(s)
    Hello,
    Looking for some help with a front strut replacement on a C6 allroad. Compressor has been serviced using Andyís fine refurb kit! Rear airbags replaced a couple of years ago. Front left replaced 6 months ago. Finally got around to replacing the front right strut (had a slow leak but was still functional). After fitting new strut from eBay the car sat about 2cm lower at that corner at all levels. Took it for a test drive and it understeered badly when front right put under load, causing ABS to kick in. Removed the eBay strut and put the original back on and everything fine again. When we had the 2 next to each other on the bench there was no obvious difference in geometry. So I returned to the eBay seller who sent out a replacement...which has exactly the same problem. So my question is - is there a procedure to recalibrate the suspension after fitting a new strut that Iím missing? (Didnít do anything specific for the other 3 corners and didnít have any problems). Or is this a dodgy batch of struts? Anyone had similar problems?
    Thanks in advance for any advice!
     
    0 0 0
     

  3. Re: Allroad Air Suspension Compressor strip & repair 
    Join Date
    Jul 2009
    Location
    cheshire
    Posts
    10
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    1 Post(s)
    If you see on the allroad suspension thread i was advised to swap air springs and not struts as cheap Chinese struts may well be an issue, perhaps as you are finding?

    Are you able to reuse previous audi strut? Was your issue leaking air springs or the actual strut?
     
    0 0 0
     

  4. Re: Allroad Air Suspension Compressor strip & repair 
    Join Date
    Aug 2020
    Location
    Chester
    Posts
    3
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    0 Post(s)
    Quote Originally Posted by frazered View Post
    If you see on the allroad suspension thread i was advised to swap air springs and not struts as cheap Chinese struts may well be an issue, perhaps as you are finding?

    Are you able to reuse previous audi strut? Was your issue leaking air springs or the actual strut?
    Thanks for the reply.

    I was replacing preemptively as the car is 12 yrs old and all other 3 airbags have failed over the last 2- 3 years so i figured this one will be on its way out soon too. I can only find complete struts available for the C6, unlike for the C5 where the airbag is available separately. I will certainly look into whether I could use the new airbag on the old strut. Anyone have any advice on striping down a C6 strut to fit a new airspring?

    thanks
     
    0 0 0
     

  5. Re: Allroad Air Suspension Compressor strip & repair 
    Join Date
    Jan 2007
    Location
    Nottingham, England
    Posts
    38,612
    Post Thanks / Like
    Blog Entries
    2
    Mentioned
    67 Post(s)
    Tagged
    1 Thread(s)
    Quoted
    1229 Post(s)
    We have nearly finished the FULL rear end rebuild on our 2005 4B Allroad with everything blasted and powder coated and using the full range of new Powerflex bushes, we are doing it to help promote the kit.

    A petition has been started to allow the use of synthetic fuels when they become available, this may allow the continued sale of ICE vehicles post 2030 and the use of classic vehicles well into the futureÖ Their use may even be able to rival electric vehicles given the chance. Please sign this petition IF you feel the infernal combustion engine has a future if sustainable fuels are made available


    https://petition.parliament.uk/petitions/588774
     
    0 0 0
     

  6. Re: Allroad Air Suspension Compressor strip & repair 
    Join Date
    Aug 2020
    Location
    Derbyshire
    Posts
    1
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    0 Post(s)
    Thanks to everyone on this thread for their invaluable information. Having recently bought an Allroad, it's great that I can read up and find similar faults and ways to fix them, and I plan on doing as much as I can to keep this lovely car running smoothly.
    My car started to have suspension problems (not reaching the desired level, getting the orange warning symbol on the dash, and having to turn engine off then on again to get the compressor to run again) and it was steadily getting worse (taking up to 5 engine switch offs to get the car to the right level!).
    I started to do the overnight checks for air leaks (put at certain height, put into 'jack mode', check next morning) but didn't see any drops in height in any corner.
    When I first got under the car I noticed one of the pipes ( I think it's the air supply pipe) was disconnected as the jubilee clip had rusted away. So I reconnected with a new jubilee clip and tried to raise the level of the car, but it still took a few goes to get to the right level. I did notice that by replacing the pipe, the car didn't hiss as loudly when dropping a level, which it has been doing previously.
    I then found a compressor piston ring repair kit and replaced it, and since then the car has been miles better, getting to the right level, only a few orange warning lights (this happened when car was stationary, so I'm assuming it got too warm).
    My only issue now is that the compressor seems to be vibrating a lot more, and I had noticed that there was only 1 spring on the 3 mounting points, I'm assuming the previous owner didn't replace the springs when he had the compressor 'reconditioned'. When the compressor is running, it seems to vibrate a lot until I put my hand on it, which I assume means it needs something more to dampen the vibration.
    Can anyone point me in the right direction where I can purchase a few more springs, and hopefully reduce the vibration and noise.
    Thanks for the help so far!
    Cheers
    Sam
     
    0 0 0
     

  7. Re: Allroad Air Suspension Compressor strip & repair 
    Join Date
    Nov 2020
    Location
    United Kingdom
    Posts
    3
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    0 Post(s)
    Hi all magnificent info. Where would be the best place to buy a left front air bag for a 2006 Audi Allroad Quattro 2.7tdi
    Thanks
     
    0 0 0
     

  8. Re: Allroad Air Suspension Compressor strip & repair 
    Join Date
    Jan 2007
    Location
    Nottingham, England
    Posts
    38,612
    Post Thanks / Like
    Blog Entries
    2
    Mentioned
    67 Post(s)
    Tagged
    1 Thread(s)
    Quoted
    1229 Post(s)
    2006my is the only year there was no Allroad, 4B >2005 and 4F 2007>. Aftermarket air bags such as Arnot are OK but they don't last as long as genuine but at £890.30 each genuine ones are daft, if you Google the part number, 4F7 616 051 D, there are a lot to choose from for as little as £38 from Amazon.
    A petition has been started to allow the use of synthetic fuels when they become available, this may allow the continued sale of ICE vehicles post 2030 and the use of classic vehicles well into the futureÖ Their use may even be able to rival electric vehicles given the chance. Please sign this petition IF you feel the infernal combustion engine has a future if sustainable fuels are made available


    https://petition.parliament.uk/petitions/588774
     
    0 0 0
     

Page 46 of 46 FirstFirst ... 36444546

Similar Threads

  1. Allroad suspension compressor purchasing.
    By Tommer9 in forum Audi A6 - C5 Forum - 1998 - 2004
    Replies: 4
    Last Post: 29-03-2012, 10:08 PM
  2. Allroad air suspension compressor
    By douglasiain in forum Audi A6 - C5 Forum - 1998 - 2004
    Replies: 2
    Last Post: 06-09-2011, 12:38 PM
  3. Allroad suspension air compressor part no
    By vinpetrol in forum Audi A6 - C5 Forum - 1998 - 2004
    Replies: 10
    Last Post: 09-06-2011, 09:51 PM
  4. Allroad suspension compressor
    By 27allroadpetrol in forum Audi A6 - C5 Forum - 1998 - 2004
    Replies: 1
    Last Post: 20-04-2011, 02:09 PM
  5. Allroad Suspension Compressor
    By Boothyboy in forum Audi A6 - C5 Forum - 1998 - 2004
    Replies: 47
    Last Post: 19-08-2010, 08:50 AM
Bookmarks
Bookmarks
Posting Permissions
  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  


 



  


Disclaimer: VW Audi Forum is an "independant enthusiast website", administered in line with guidelines supplied by VAG in the UK, and is in no way related to any of the Worldwide Volkswagen,Audi,Seat,Skoda,Bentley,Bugatti,Porsche or Lamborghini group of Companies. For official up to date information on any of there vehicles, please visit the official websites. Any comments made throughout this website, are the views of the respective poster, and in no way represent the views of the VW Audi Forum Administration, or the worldwide Volkswagen & Audi Group of companies.


VW Audi Forum do not vet and are not responsible for any information which is posted in this forum. All content is viewed and used by you at your own risk and we do not warrant the accuracy or reliability of any of the information.


Copyright: Certain "words", "phrases" and "Images" used on this website by the Administration are "Copyright" of Volkswagen GB, Volkswagen AG (Germany), Audi GB, Audi AG (Germany), Volkswagen Motorsport GB, Volkswagen Motorsport AG (Germany), Audi Motorsport AG (Germany), Volkswagen Racing GB, Bentley, Bugatti, Porsche and Lamborghini. No image can be replicated by anyone WITHOUT the relevant Companies written permission.


All trademarks and copyrights remain property of their respective owners.

No part of the VW Audi Forum website or forum may be reproduced without written permission from the site administration


PLEASE NOTE - PERSONAL ABUSE, ABUSE AGAINST THIS OR ANY OTHER WEBSITE OR ANY COMPANY WILL NOT BE TOLERATED. OFFENDERS WILL BE MODERATED OR EVEN BANNED.


This website and forum are best viewed at a minimum resolution of 1024 by 768.



  



- VW AUDI Forum - The #1 Volkswagen (VW) Group Forum - Volkswagen (VW) - Audi - Seat - Skoda - Bentley - Bugatti - Lamborghini - Porsche - Scania - MAN - Ducatti - VW Audi Forum -


- www.vwaudiforum.co.uk - www.vwaudiforum.co.uk -