Signs of Dmf failure on a Dsg.
Hi guys, just had my cambelt and water pump replaced by my friend at his garage. Job was carried out no problem!! But, by leaving the car on tick over to check everything is ok. Car has a noticable rumble from the gearbox. Sounds like dmf failure :-(:-( I have had zero problems with my sat and to be honest unless it becomes undriveable it will stay. Car drives fine no slip from the box.
So my question is this. When I drove back home and parked the car it had no noise what so ever how come?. Also how much would it cost to replace? Ideas, suggestions?
Thanks, Rappy.
Re: Signs of Dmf failure on a Dsg.
Get the bonnet open cold Rappy, if it's what I think you are hearing it sounds like a dry bearing that does indeed quieten down when warmed up, this will probably develop into what sounds like a pebble going round in a washing machine and is an indication the DMF is on it's way,
A mate had one done on his Octavia a few mths ago at an Indy, iirc it cost about £550 all in, the flywheel itself is about £350 - £450 from a motor factors, expect VW to hurl a figure of £1000 though.
Something else to try as well, hit the brakes sharp and see if it feels like something has travelled on when the car has stopped, like a loose box in the boot, and does the car sound rough when starting it, like the starter motor is falling out?
Re: Signs of Dmf failure on a Dsg.
I drive around 85 miles a day. So the car is never really cold. If you look at it most dmfs fail around 100k mine has covered nearly 90k and showing signs.
I cant really fault vw as its simply wear and tear. I have heard that the old dmfs are replaced with a newer heavier duty one. Also Vw may offer to pay a % of the bill. Car is due its dsg oil and filter change in 4mths, so I may ask the local vw dealer if they can help.
Will it get like a manual dmf? Car will slip in gears when pulling away?.
Re: Signs of Dmf failure on a Dsg.
Checked car this morning and its there. Dry bearing/ pebble in a tumble dryer.
Re: Signs of Dmf failure on a Dsg.
DMF failure doesn't cause slip in gears, only clutches slip. The earliest sign of DMF problems is the extra rattle as the front plate rocks against the back one. This often "gets better" when the front plate seizes in one spot. Failure is difficult to diagnose even when you listen to the car. Explaining it here is almost impossible. You can remove a gearbox to do a clutch change and find the dmf siezed but no advanced warning.
Re: Signs of Dmf failure on a Dsg.
I think mine has very early signs of dmf failure. My understanding of the dmf is it wrong? I thought the dmf smoothed the gear change and if worn could cause the clutch to slip as it wont be as smooth when changing gear.
Based on what you have said Martin what will happen then?
Re: Signs of Dmf failure on a Dsg.
@ rapport25,
Mine is a 2007 B6 2.0TDi SEL DSG passat. IIRC When the DMF started going on mine (90,000 Mile mark), the car used to jerk violently forward almost like a start stop start stop motion and it was always at slow speeds undr 30mph mostly in traffic.
I remember the dealership saying there is no way of checking unless you open up the gearbox. I saved up and bought a DMF from TPS (trade part specialists). Replaced it and have never had the problem since. It does progressively get worse so if you can best to sort it out early. PM me and I can get you a price from TPS if you need something to compare whatever you have been quoted with.
Re: Signs of Dmf failure on a Dsg.
Quote:
Originally Posted by
Pireeeh
@ rapport25,
Mine is a 2007 B6 2.0TDi SEL DSG passat. IIRC When the DMF started going on mine (90,000 Mile mark), the car used to jerk violently forward almost like a start stop start stop motion and it was always at slow speeds undr 30mph mostly in traffic.
I remember the dealership saying there is no way of checking unless you open up the gearbox. I saved up and bought a DMF from TPS (trade part specialists). Replaced it and have never had the problem since. It does progressively get worse so if you can best to sort it out early. PM me and I can get you a price from TPS if you need something to compare whatever you have been quoted with.
Thanks, I have already sourced an Luk dmf they are £350. Have done a fair bit of reading. Main dealers offering good will etc..... If I can get it done for £500 all in I will be happy. As mentioned above mine drives fine. My mechanic has drawn my attention to it. And said to get it checked at vw. He has zero experience working on dsgs.
What price did you pay parts? and labour?.
Re: Signs of Dmf failure on a Dsg.
Got to work this morning and there is a very slight rumble noise when warm. Unsure if its me being paranoid :-).
