2.0 TDI oil pump / balance shaft failure

[bakili]

Sorry guys for bad news,

Last week I had phone call from my mechanic (trained Audi technician) to bring my car urgently in so he can check for oil pump / balance shaft failure.
I was aware about this problem, and I knew A4 and older engines were effected, as my engine is BRE I was calm. He told me that in past week he had 2 C6 with same issue and both are still in workshop. So I went to see him, and to my shock both C6 were BRE engines and under 80k. Owners of both cars were facing £2500+ repair bill.
After checking my chassis number, to my luck my car was build after September 2006, and even being BRE engine, parts were upgraded. He told me that my car is 7th chassis and it should be OK.
I would strongly advice to get it checked.

[Reidy]

My 05 2.0 tdi has already done 140000 miles. Guessing if anything like that was gonna fail it would have by now

[johnloaderuk]

Interesting article here http://www.myturbodiesel.com/1000q/b...passat-tdi.htm

[joshA6]

Sorry guys for bad news,

Last week I had phone call from my mechanic (trained Audi technician) to bring my car urgently in so he can check for oil pump / balance shaft failure.
I was aware about this problem, and I knew A4 and older engines were effected, as my engine is BRE I was calm. He told me that in past week he had 2 C6 with same issue and both are still in workshop. So I went to see him, and to my shock both C6 were BRE engines and under 80k. Owners of both cars were facing £2500+ repair bill.
After checking my chassis number, to my luck my car was build after September 2006, and even being BRE engine, parts were upgraded. He told me that my car is 7th chassis and it should be OK.
I would strongly advice to get it checked.

Hey Bakili, how can you tell if you car is 7th chasis. I have a june 08 BRE TDi and am curious to know if it owuld have had the upgraded parts?

Anything you can add to put my mind at rest would be a great help

[bakili]

Hey JoshA6
My car is 56 reg December, i been told 7th chassis are cars build 2006 Sept +

[a8 tech]

Hey JoshA6
My car is 56 reg December, i been told 7th chassis are cars build 2006 Sept +

Do not rely on vin year as that is the car not the engine and 2007 is affected by the failures
Sump off and inspect it's the only way or to check oil pressure address 17 mvb 3 oilpok notok but as the hex key wear can go undetected by this its best to remove and inspect




Sent from my iPhone using
My fat fingers