Notices
 

  

User Tag List

Thread: Passenger front door problems!

Results 1 to 9 of 9
  1. Passenger front door problems! 
    #1
    Join Date
    Aug 2017
    Location
    West Midlands UK
    Posts
    63
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    11 Post(s)
    Can anyone offer some advice please?

    My passenger front door has always been a bit temperamental, if it's slammed or even closed firmly it won't shut properly and has drained the battery a few times with the courtesy lights staying on for long periods.

    It started after a local joey was recruited to change the window winder reg as it had failed on the previous owner, the last owner complained about it and the mechanic said that the door was out of alignment or some other BS and refused to rectify the new problem.

    The door needs to be lifted slightly as it's closed now and if I squirt a little WD40 into the lock it improves it but in the cold weather it just will not shut properly whatsoever, it's so infuriating and takes a long time.

    I now have to grab the door handle and give it a sharp tug from inside to latch it, obviously this is upsetting the door handle and door card trim, I reckon the handle will come off one day.

    It's a real pain as passengers always slam the door - even when you ask them not to, I have to grab it and close it myself from the drivers seat.

    The lock does work, something is out of alignment.

    I've read the door lock might need de-greasing and cleaning up, any pointers please?

    Thanks guys.
    2003 A6 C5 2.5 TDI Quattro Avant (180bhp)
     
    0 0 0
     

  2. Re: Passenger front door problems! 
    #2
    Join Date
    Nov 2016
    Location
    Swindon
    Posts
    173
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    13 Post(s)
    Quote Originally Posted by Stavros_Davros View Post
    Can anyone offer some advice please?

    My passenger front door has always been a bit temperamental, if it's slammed or even closed firmly it won't shut properly and has drained the battery a few times with the courtesy lights staying on for long periods.

    It started after a local joey was recruited to change the window winder reg as it had failed on the previous owner, the last owner complained about it and the mechanic said that the door was out of alignment or some other BS and refused to rectify the new problem.

    The door needs to be lifted slightly as it's closed now and if I squirt a little WD40 into the lock it improves it but in the cold weather it just will not shut properly whatsoever, it's so infuriating and takes a long time.

    I now have to grab the door handle and give it a sharp tug from inside to latch it, obviously this is upsetting the door handle and door card trim, I reckon the handle will come off one day.

    It's a real pain as passengers always slam the door - even when you ask them not to, I have to grab it and close it myself from the drivers seat.

    The lock does work, something is out of alignment.

    I've read the door lock might need de-greasing and cleaning up, any pointers please?

    Thanks guys.
    For fixing the door closing issue, you will need a new lock.
     
    0 0 0
     

  3. Re: Passenger front door problems! 
    #3
    Join Date
    Aug 2017
    Location
    West Midlands UK
    Posts
    63
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    11 Post(s)
    Damn! I bet they are expensive.

    Any idea which part of the lock fails?

    Strange it only happened after the window reg was changed, remember I mentioned the mechanic said the door was out of alignment? could he have messed it up?

    I don't really think he knows what he's doing as he fitted a set of front brake pads on my Zafira the wrong way around a few weeks back - he won't be touching any of my cars again for sure.

    Could anyone advise the Audi part number please so I can match a pattern part?

    2003 A6 B4 C5 Avant SE Sport 2.5TDI Quattro (180bhp)
    2003 A6 C5 2.5 TDI Quattro Avant (180bhp)
     
    0 0 0
     

  4. Re: Passenger front door problems! 
    #4
    Join Date
    Feb 2008
    Location
    Birmingham
    Posts
    325
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    4 Post(s)
    They are around 200 from audi. You can get them cheaper on eBay but I have bought good second hand ones that have lasted well.


    Sent from my iPhone using Tapatalk
     
    0 0 0
     

  5. Re: Passenger front door problems! 
    #5
    Join Date
    Nov 2011
    Location
    Duns Scotland
    Posts
    570
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    6 Post(s)
    First off, if the door is out of alignment such that it will not close properly, you should be able to see its out. Adjusting is easy - simply loosen the four bolts (2 at each hinge) - adjust and then tighten. However, iits hard to see how it got like that unless the door has been adjusted (incorrectly) or removed before.
    If you need a new lock, I can give you one - postage cost only. I recently replaced both doors on my 2002 Allroad. I can also give you details on how to do this job - its a bit fiddly with the hardest part being how to rease the old lock from the lock recess. Use the lock I would send you to see how the release mechanism works - it was not obvious (to me). Obviously you reuse your lock cylinder.
    let me know and If you wish me to send the lock - I would be tuesday before I could send.
     
    0 0 0
     

  6. Re: Passenger front door problems! 
    #6
    Join Date
    Aug 2017
    Location
    West Midlands UK
    Posts
    63
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    11 Post(s)
    Quote Originally Posted by ceilidhalfie View Post
    First off, if the door is out of alignment such that it will not close properly, you should be able to see its out. Adjusting is easy - simply loosen the four bolts (2 at each hinge) - adjust and then tighten. However, iits hard to see how it got like that unless the door has been adjusted (incorrectly) or removed before.
    If you need a new lock, I can give you one - postage cost only. I recently replaced both doors on my 2002 Allroad. I can also give you details on how to do this job - its a bit fiddly with the hardest part being how to rease the old lock from the lock recess. Use the lock I would send you to see how the release mechanism works - it was not obvious (to me). Obviously you reuse your lock cylinder.
    let me know and If you wish me to send the lock - I would be tuesday before I could send.
    from what I can tell the window regulator failed on the previous owner and he had a local indy mechanic come and fit a new window reg mech, the door worked fine previously apparently. After refitting the new reg he claimed that the door wasn't true or twisted or something and wouldn't line up to close properly after, he said he'd spent a day trying to make it line up and close properly, I'm not sure whether he didn't mark the sliding bolts when removing the window frame - if that would make a difference?

    The door when it needs closing, has to be lifted slightly, you can see the door 'ride up' when it hooks onto the stricker latch, if its been left some days it just will not close, 20, 30 attempts and it just won't latch to make the courtesy light go out at the rear of the door or extinguish the dash warning that the door is open.

    If I spray some WD40 onto the latch - the door closes instantly, first shot and is fine all that day, next day - back to square one.

    I'm not convinced the door latch is broken I think it's an alignment issue and the door is sitting too low, I've seen some internet jabber to suggest that sometimes the hinges wear and need shimming but you'd think that would be on the drivers door due to excessive use and not the passenger door .

    I haven't had a good look at the problem yet but if I can adjust the door stricker latch or the hinge height as you've suggested it may solve the problem and negate the need for a time consuming strip down and replacing the lock mech.

    Thanks for the offer - very generous, I'll bear it in mind and it is a possibility, let me have a look at the door height and see if I can adjust it first, you'd think a competent mechanic would have had no trouble with this but I've seen other incompetency he's committed on this car and more recently on my other! never again!

    I'll be in touch but in the meantime if you have any more suggestions based on the info I've given I'm all ears!
    2003 A6 C5 2.5 TDI Quattro Avant (180bhp)
     
    0 0 0
     

  7. Re: Passenger front door problems! 
    #7
    Join Date
    Nov 2011
    Location
    Duns Scotland
    Posts
    570
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    6 Post(s)
    Feel free to adjust the door at the hinges - its no big deal and easily adjusted back again if you end up with a bigger problem. When I changed both front doors on my Allroad, I could hear a terrible wind noise from the passenger door. On inspection I could see it was out at the side near the top hinge. As I said above, a quick slacken - adjust - retighten and problem fixed. If you need to lift the door to get it to close you definitely need to raise it at the hinges - I would suggest slacken both hinges and lift slightly. You can clearly see when you close it if it needs to go up or down, or out/in at top or bottom.
     
    0 1 0
     

  8. Re: Passenger front door problems! 
    #8
    Join Date
    May 2015
    Location
    Kirmington, North Lincolnshire
    Posts
    80
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    4 Post(s)
    If I spray some WD40 onto the latch - the door closes instantly, first shot and is fine all that day, next day - back to square one.
    The solvents in WD40 will dry out leaving you back where you started.

    I have the same issue with mine, its been 6 years now and I've tried GT85 which is a better lubricant, if I had another go I would probably use a light oil/spray which will not dry out over time.
    2003 Audi A6 Avant 1.9 tdi Sport
     
    0 0 0
     

  9. Re: Passenger front door problems! 
    #9
    Join Date
    Jan 2017
    Location
    Dublin
    Posts
    74
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    1 Post(s)
    Have same issue with mine
    Learned to live with it as it does not effect lights on
    Fitted new lock made no difference
    I am like a chaffeur when I close it,like you said I have to lift my door and gentle push will close it,slam it and it will bounce of the steel bracket
     
    0 0 0
     

Similar Threads

  1. Please Help 2007 Touran - Front passenger door lock failed and can't open door
    By Scottiedogg in forum Touran - Sharan - Caravelle
    Replies: 1
    Last Post: 24-08-2017, 11:49 AM
  2. Replies: 2
    Last Post: 24-04-2015, 10:17 AM
  3. Golf plus passenger front door
    By rodie in forum Golf Plus
    Replies: 1
    Last Post: 19-09-2012, 09:06 PM
  4. Passenger side front door window motor (3 door)
    By swm1982 in forum Golf MK5 - 2004 - 2009
    Replies: 0
    Last Post: 06-01-2012, 12:59 AM
  5. Front Passenger Door
    By Trev.W in forum Passat - B6 Forum - 2005 - 2010
    Replies: 4
    Last Post: 09-11-2009, 08:10 PM
Bookmarks
Bookmarks
Posting Permissions
  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  




  


Disclaimer: VW Audi Forum is an "independant enthusiast website", administered in line with guidelines supplied by VAG in the UK, and is in no way related to any of the Worldwide Volkswagen,Audi,Seat,Skoda,Bentley,Bugatti,Porsche or Lamborghini group of Companies. For official up to date information on any of there vehicles, please visit the official websites. Any comments made throughout this website, are the views of the respective poster, and in no way represent the views of the VW Audi Forum Administration, or the worldwide Volkswagen & Audi Group of companies.


VW Audi Forum do not vet and are not responsible for any information which is posted in this forum. All content is viewed and used by you at your own risk and we do not warrant the accuracy or reliability of any of the information.


Copyright: Certain "words", "phrases" and "Images" used on this website by the Administration are "Copyright" of Volkswagen GB, Volkswagen AG (Germany), Audi GB, Audi AG (Germany), Volkswagen Motorsport GB, Volkswagen Motorsport AG (Germany), Audi Motorsport AG (Germany), Volkswagen Racing GB, Bentley, Bugatti, Porsche and Lamborghini. No image can be replicated by anyone WITHOUT the relevant Companies written permission.


All trademarks and copyrights remain property of their respective owners.

No part of the VW Audi Forum website or forum may be reproduced without written permission from the site administration


PLEASE NOTE - PERSONAL ABUSE, ABUSE AGAINST THIS OR ANY OTHER WEBSITE OR ANY COMPANY WILL NOT BE TOLERATED. OFFENDERS WILL BE MODERATED OR EVEN BANNED.


This website and forum are best viewed at a minimum resolution of 1024 by 768.



  



- VW AUDI Forum - The #1 Volkswagen (VW) Group Forum - Volkswagen (VW) - Audi - Seat - Skoda - Bentley - Bugatti - Lamborghini - Porsche - VW Audi Forum -


- www.vwaudiforum.co.uk - www.vwaudiforum.co.uk -