Notices
 
 

  

User Tag List

Thread: Audi d3 exhaust gas temp sensor fault code advice

Page 1 of 2 12 LastLast
Results 1 to 10 of 14
  1. Audi d3 exhaust gas temp sensor fault code advice 
    #1
    Join Date
    May 2017
    Location
    GB
    Posts
    27
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    0 Post(s)
    Hi guys.

    I have the folowing Error. See Pic.

    My question is What's the part No apparently there are 3 or 4 sensors on the d3 for exhaust. Which one do I need and roughly how much am I looking at in terms of cost of part and cost of labour .

    Thanks

    Sent from my SM-N950F using Tapatalk
     
    0 0 0
     

  2. Re: Audi d3 exhaust gas temp sensor fault code advice 
    #2
    Join Date
    Jan 2007
    Location
    Nottingham, England
    Posts
    42,103
    Post Thanks / Like
    Blog Entries
    4
    Mentioned
    108 Post(s)
    Tagged
    1 Thread(s)
    Quoted
    1816 Post(s)
    On my iPad so I can't give you the number but I think these are genuine only so you should get what you need from a TPS or Audi dealer by quoting the SDC code G235 after they have entered your VIN into ETKA.
    Anthropogenic climate change, the biggest con inflicted on mankind since religion...

    Slava Ukraini
    !


     
    0 1 0
     

  3. Re: Audi d3 exhaust gas temp sensor fault code advice 
    #3
    Join Date
    May 2017
    Location
    GB
    Posts
    27
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    0 Post(s)
    Called tps today and they can't for sure say which one I need. There are 2 possibilities apparently both of which are before the manifold. So I guess the only real way to find out it to get it checked.

    Sent from my SM-N950F using Tapatalk
     
    0 0 0
     

  4. Re: Audi d3 exhaust gas temp sensor fault code advice 
    #4
    Join Date
    Jan 2007
    Location
    Nottingham, England
    Posts
    42,103
    Post Thanks / Like
    Blog Entries
    4
    Mentioned
    108 Post(s)
    Tagged
    1 Thread(s)
    Quoted
    1816 Post(s)
    It is listed on ETKA as a G235, PM me your reg number and when I get back from darkest Wales to civilisation, I will look it up for you.
    Anthropogenic climate change, the biggest con inflicted on mankind since religion...

    Slava Ukraini
    !


     
    0 0 0
     

  5. Re: Audi d3 exhaust gas temp sensor fault code advice 
    #5
    Join Date
    May 2017
    Location
    GB
    Posts
    27
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    0 Post(s)
    Quote Originally Posted by Crasher View Post
    It is listed on ETKA as a G235, PM me your reg number and when I get back from darkest Wales to civilisation, I will look it up for you.
    Thanks. Ov05obm

    Sent from my SM-N950F using Tapatalk
     
    0 0 0
     

  6. Re: Audi d3 exhaust gas temp sensor fault code advice 
    #6
    Join Date
    Jan 2007
    Location
    Nottingham, England
    Posts
    42,103
    Post Thanks / Like
    Blog Entries
    4
    Mentioned
    108 Post(s)
    Tagged
    1 Thread(s)
    Quoted
    1816 Post(s)
    I forgot to update my home version of ETKA with my new password so I can't get FI suggestion on the sensor until Monday t work. Guessing a few of the cars details using the 4E type number and ASE engine code I can see G235 as being EGT sensor 1 for bank one which is the right hand side in the right turbo, mounted in the turbine housing itself and has the part number 057 906 088 which retails at £147.38 from Audi or TPS.
    Anthropogenic climate change, the biggest con inflicted on mankind since religion...

    Slava Ukraini
    !


     
    1 1 0
     

  7. Re: Audi d3 exhaust gas temp sensor fault code advice 
    #7
    Join Date
    May 2017
    Location
    GB
    Posts
    27
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    0 Post(s)
    Appreciate the help. Let me as soon as you do if it is defo right hand side so I can place an order.

    Thanks

    Sent from my SM-N950F using Tapatalk
     
    0 0 0
     

  8. Re: Audi d3 exhaust gas temp sensor fault code advice 
    #8
    Join Date
    Jan 2007
    Location
    Nottingham, England
    Posts
    42,103
    Post Thanks / Like
    Blog Entries
    4
    Mentioned
    108 Post(s)
    Tagged
    1 Thread(s)
    Quoted
    1816 Post(s)
    The SDC code G235 in ETKA does not differentiate between left and right, using the workshop system ELSA shows G235 to be "exhaust gas temperature sender 1" and the other side is described as "exhaust gas temperature sender 1 for bank 2 -G236-" so from that we can assume G235 is bank 1 which is the right hand bank as viewed from the drivers seat locking forwards. This means the part number is 057 906 088, the Audi procedure is as follows

    Removing

    All cable ties which are released or cut open when removing must be fitted in the same position when installing.

    Remove starter catalytic converter

    Unplug electrical connector and unscrew exhaust gas temperature sender 1 -G235

    Installing

    Installation is carried out in the reverse order; note the following:

    Fit all cable ties in the original positions when installing.

    Note correct installation position of exhaust gas temperature sender 1 -G235-:

    The electrical connection must point downwards in vertical direction.

    Install starter catalytic converter .
    Anthropogenic climate change, the biggest con inflicted on mankind since religion...

    Slava Ukraini
    !


     
    1 1 0
     

  9. Re: Audi d3 exhaust gas temp sensor fault code advice 
    #9
    Join Date
    May 2017
    Location
    GB
    Posts
    27
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    0 Post(s)
    Nice 1!

    Sent from my SM-N950F using Tapatalk
     
    0 0 0
     

  10. Re: Audi d3 exhaust gas temp sensor fault code advice 
    #10
    Join Date
    May 2017
    Location
    GB
    Posts
    27
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    0 Post(s)
    Update.

    I popped over to the local dealer and ordered the above part. It will take around a week as it's shipped from Germany.

    Sent from my SM-N950F using Tapatalk
     
    0 0 0
     

Page 1 of 2 12 LastLast

Similar Threads

  1. Fix Audi code 01032 Exhaust Gas Recirculation Sensor B & 01027 Exhaust Gas Rec Circuit
    By niall campbell in forum Audi A6 - C6 Forum - 2005 - 2010
    Replies: 5
    Last Post: 13-12-2017, 02:57 PM
  2. Audi A4 B8 2.0Tdi Exhaust Gas Temp sensor
    By aaron.ivory.31 in forum Audi A4 - B8 Forum - 2008 - 2015
    Replies: 0
    Last Post: 08-01-2015, 12:22 AM
  3. EML light on and fault code 005212 - Exhaust Gas Temperature Sensor 3
    By Scottiedogg in forum Passat - B6 Forum - 2005 - 2010
    Replies: 2
    Last Post: 20-01-2013, 09:56 PM
  4. Exhaust Gas Temp Sensor
    By Dougster67 in forum Audi A3 - 8P - 2004 - 2012
    Replies: 0
    Last Post: 17-09-2011, 05:07 PM
  5. URGENT HELP - exhaust/NOX/Gas temp sensor
    By lyndon79 in forum New Member Introductions
    Replies: 3
    Last Post: 14-12-2009, 03:20 PM
Bookmarks
Bookmarks
Posting Permissions
  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  


 



  


Disclaimer: VW Audi Forum is an "independant enthusiast website", administered in line with guidelines supplied by VAG in the UK, and is in no way related to any of the Worldwide Volkswagen,Audi,Seat,Skoda,Bentley,Bugatti,Porsche or Lamborghini group of Companies. For official up to date information on any of there vehicles, please visit the official websites. Any comments made throughout this website, are the views of the respective poster, and in no way represent the views of the VW Audi Forum Administration, or the worldwide Volkswagen & Audi Group of companies.


VW Audi Forum do not vet and are not responsible for any information which is posted in this forum. All content is viewed and used by you at your own risk and we do not warrant the accuracy or reliability of any of the information.


Copyright: Certain "words", "phrases" and "Images" used on this website by the Administration are "Copyright" of Volkswagen GB, Volkswagen AG (Germany), Audi GB, Audi AG (Germany), Volkswagen Motorsport GB, Volkswagen Motorsport AG (Germany), Audi Motorsport AG (Germany), Volkswagen Racing GB, Bentley, Bugatti, Porsche and Lamborghini. No image can be replicated by anyone WITHOUT the relevant Companies written permission.


All trademarks and copyrights remain property of their respective owners.

No part of the VW Audi Forum website or forum may be reproduced without written permission from the site administration


PLEASE NOTE - PERSONAL ABUSE, ABUSE AGAINST THIS OR ANY OTHER WEBSITE OR ANY COMPANY WILL NOT BE TOLERATED. OFFENDERS WILL BE MODERATED OR EVEN BANNED.


This website and forum are best viewed at a minimum resolution of 1024 by 768.



  



- VW AUDI Forum - The #1 Volkswagen (VW) Group Forum - Volkswagen (VW) - Audi - Seat - Skoda - Bentley - Bugatti - Lamborghini - Porsche - Scania - MAN - Ducatti - VW Audi Forum -


- www.vwaudiforum.co.uk - www.vwaudiforum.co.uk -