Passat 2008 2.0CR TDI EML and flashing glow plug light

[jasonmking]

Hi

I have posted on here before about this but the problem seems to have changed

first of when you start the car it runs ok for the first few miles then the power starts to fade away If you then come across a hill for example and apply power to car will then go into limp mode If you then switch off the engine and back on again it seems to reset and again is ok for a few miles and the power is back to normal

Now when I start the car the eml comes on and the glow plug light starts to flash after about 500 yards of driving but the power is still there and then starts to fade after about 5 miles of driving

also not sure if its my imagination but its seems to be worse if I dont use the car for a day or 2 and if cold

many thanks

jason

[Guest 2]

Ideally you need a fault code scan done.

[jasonmking]

Thanks Chris

would I be able to read these with the VCDS lite version

Thanks

jason

[martin1810]

Thanks Chris

would I be able to read these with the VCDS lite version

Thanks

jason

No. You need fulll vcds to read this car. A common fault on these is failed boost actuator, but you need a scan to confirm it.

[jasonmking]

Thanks Martin

I will find someone locally hopefully that will have these and see what it comes up with

[jasonmking]

Had my codes read today and this is what came back

Address 01: Engine (CBA) Labels: 03L-906-022-CBA.clb
Part No SW: 03L 906 022 FN HW: 03L 907 309
Component: R4 2,0L EDC G000SG 2643
Revision: --H01--- Serial number: VWZCZ000000000
Coding: 0000072
Shop #: WSC 05311 000 08193
VCID: 76E9977C7FDE


4 Faults Found:
000665 - Boost Pressure Regulation: Control Range Not Reached
P0299 - 000 - - - MIL ON
Freeze Frame:
Fault Status: 11100000
Fault Priority: 2
Fault Frequency: 12
Mileage: 182527 km
Time Indication: 0
Date: 2013.03.25
Time: 12:27:45


Freeze Frame:
RPM: 2369 /min
Speed: 101.0 km/h
Absolute Pres.: 2213.4 mbar
Absolute Pres.: 1275.0 mbar
Temperature: 2.7°C
Mass Air / Rev.: 615.0 mg/str
Lambda: 15.0 %


008451 - Throttle Valve Actuator Module (J338): Motor Circuit: Signal High
P2103 - 000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 2
Fault Frequency: 32
Mileage: 182544 km
Time Indication: 0
Date: 2013.03.25
Time: 12:38:22


Freeze Frame:
RPM: 1012 /min
Speed: 63.0 km/h
Load: 0.0 %
Load: 9.0 %
Lambda: 100.2 %
Mass Air / Rev.: 485.0 mg/str
Temperature: 89.1°C


008465 - Throttle Actuator Control System: Stuck Open
P2111 - 000 - - - Intermittent - MIL ON
Freeze Frame:
Fault Status: 10100000
Fault Priority: 2
Fault Frequency: 20
Mileage: 183998 km
Time Indication: 0
Date: 2013.04.05
Time: 16:26:40


Freeze Frame:
RPM: 1932 /min
Speed: 49.0 km/h
Load: 36.5 %
Load: 12.9 %
Lambda: 100.2 %
Mass Air / Rev.: 560.0 mg/str
Temperature: 89.1°C


008448 - Throttle Actuator Control Circuit: Open
P2100 - 000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 2
Fault Frequency: 2
Mileage: 184007 km
Time Indication: 0
Date: 2013.04.05
Time: 16:33:05


Freeze Frame:
RPM: 2001 /min
Speed: 50.0 km/h
Load: 32.5 %
Load: 12.9 %
Lambda: 100.2 %
Mass Air / Rev.: 565.0 mg/str
Temperature: 89.1°C


Readiness: 1 2 0 0 0

Maybe not the turbo then but is this an easy fix

thanlks