Notices
 
 

  

User Tag List

Thread: Swirl flaps - are they worth it?

Page 1 of 8 123 ... LastLast
Results 1 to 10 of 75
  1. Swirl flaps - are they worth it? 
    #1
    Join Date
    Sep 2007
    Location
    Bookham, Surrey
    Posts
    313
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    1 Post(s)
    Anyone got any thoughts on the value of the swirl flaps in the V6 and V8 tdi engines?

    Official documentation states "They enable the airflow to be adjusted to suit engine speed and load. Not only additional power and torque result, but also lower fuel consumption and emissions."

    They seem very problematic though and expensive to fix (over £2000 to replace both sides on the V6). There's a lot on the BMW forums about completely removing them on the 2.0d and 3.0d engines with, arguably, little or no effect on performance. - see attached technical docs for how they work.

    They are basically on-off valves on one of the two inlet runners on each cylinder. Possible scenarios might be:

    1. Mechanism wears or gets a bit impaired e.g. linkage is worn giving "lower limit" error - valves still work though - no noticeable effect
    2. Motor is faulty - valves don't operate - loss of power above 1250 rpm because spiral runner is blocked
    3. Valves break off and knacker the cylinders, EGR valve and turbo

    Questions in my mind are:
    1. Why does problem 1 warrant the engine management light coming on?
    2. Are they worth the money? Any efficiency savings are wiped out by a £2000 bill after 80k for six bits of plastic and two motors
    2b. Ditto for problem 3 - a very big bill again!
    3. Why do you have to change the whole thing at once - they're only on/off valves
    4. Is there any way to put an inhibit on the lower limit error or change the tolerance to stop the light coming on?
    Attached Files
     
    0 0 0
     

  2. Re: Swirl flaps - are they worth it? 
    #2
    Join Date
    May 2009
    Location
    uk
    Posts
    154
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    2 Post(s)
    i've seen on a bmw forum the same complaints,

    i thinks its just manufactures doing what they can for the green factor maybe.

    and in the bmw forum they have a solution to remove them wich most handy diy'ers can do.

    once again the bmw forum complain about the probbability of failure and possible damage it can cause if your unlucky.
     
    0 0 0
     

  3. Re: Swirl flaps - are they worth it? 
    #3
    Join Date
    Nov 2009
    Location
    st pierre, France
    Posts
    165
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    0 Post(s)
    Just spotted this thread.

    Problem numbver 1 causes a MIL because the motor is disabled if it sees any discrepancy of I believe > 2% from expected position... The motor is spring loaded to keep the flaps open in the event of failure at ECU side.

    See the VW thread here for a great fix! https://www.vwaudiforum.co.uk/forum/s...-Swirl-Control

    A little bit of work but could be well worth it

    wjam
     
    0 0 0
     

  4. Re: Swirl flaps - are they worth it? 
    #4
    Join Date
    Nov 2009
    Location
    st pierre, France
    Posts
    165
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    0 Post(s)
    Oh.. and to answer the question... NO they are not worth it.

    Disconnect the motors and go for a long drive. I bet you see no difference worthy of their Audi cost.

    If I can find a way to take them off without a MIL I'll do it.

    wjam
     
    0 0 0
     

  5. Re: Swirl flaps - are they worth it? 
    #5
    Join Date
    Jan 2010
    Location
    Chobham, Surrey
    Posts
    245
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    1 Post(s)
    Mine have been broken for a while now. I don't see any decrease in fuel consumption on long motorway journeys. I suspect that fuel consumption is a little worse on short journeys though. I certainly don't see £2000 worth of consequences!
    Golf GT 140 TDI. Mods: RNS510
     
    0 0 0
     

  6. #6
    Join Date
    Aug 2006
    Location
    Thessaloniki, Greece
    Posts
    286
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    2 Post(s)
    How do you tell if they are broken?
    2006 Audi A6 Allroad 3.0 TDI Tiptronic
     
    0 0 0
     

  7. Re: Swirl flaps - are they worth it? 
    #7
    Join Date
    Nov 2009
    Location
    st pierre, France
    Posts
    165
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    0 Post(s)
    The engine light comes on. (MIL) But you need to get a fault diagnosis to absolutely confirm the issue.

    As a quick check you can pull of the engine cover and watch the motors after starting.

    They reference back and forth then jump to closed position for idle. Blip the throttle and you'll see them shift to open then close again as revs return to idle

    Bear in mind default position is open (so that the car runs if they fail)... Also left side is opposite direction to right side. Left side seems to fail most and I'd like to bet that's due to the extra heat from turbo right beside the plastic rod end bearings

    cheers

    wjam
     
    0 0 0
     

  8. #8
    Join Date
    Aug 2006
    Location
    Thessaloniki, Greece
    Posts
    286
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    2 Post(s)
    Thanks for the heads up mate.
    2006 Audi A6 Allroad 3.0 TDI Tiptronic
     
    0 0 0
     

  9. Re: Swirl flaps - are they worth it? 
    #9
    Join Date
    Nov 2009
    Location
    st pierre, France
    Posts
    165
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    0 Post(s)
    No probs... By the way.. 9.9 ltr / 100km? Are you driving in town a lot (like 80-% plus)? I'm getting about 8 to 8.5 ltr /100 mixed 60% motorway and 40 percent A road & mountains.

    dropping towards 8 now after remap... which i can highly recommend (superchips)

    WJAM
     
    0 0 0
     

  10. #10
    Join Date
    Aug 2006
    Location
    Thessaloniki, Greece
    Posts
    286
    Post Thanks / Like
    Mentioned
    0 Post(s)
    Tagged
    0 Thread(s)
    Quoted
    2 Post(s)
    Diesel quality in Greece is the reason. I get at least 15% more mileage when I travel in Germany or other EU countries.
    2006 Audi A6 Allroad 3.0 TDI Tiptronic
     
    0 0 0
     

Page 1 of 8 123 ... LastLast

Similar Threads

  1. Please Help Mud Flaps For a Touareg Altitude
    By bryn7 in forum Touareg
    Replies: 17
    Last Post: 12-01-2011, 07:01 PM
  2. Audi a8 2003 Current gearshift program problem
    By eints77 in forum VCDS - Help Requests
    Replies: 11
    Last Post: 20-07-2010, 02:58 PM
  3. Please Help Is it worth it?
    By lew247 in forum Octavia
    Replies: 1
    Last Post: 03-06-2010, 04:59 PM
  4. Flaps on, or, flaps off.
    By roxyland in forum Audi A4 - B7 Forum - 2005 - 2008
    Replies: 1
    Last Post: 06-03-2010, 11:15 PM
  5. Whats My Dads Car Worth?
    By SHAZA4 in forum Audi A4 - B5 Forum - 1995 - 2002
    Replies: 2
    Last Post: 18-04-2008, 03:47 PM
Tags for this Thread

View Tag Cloud

Bookmarks
Bookmarks
Posting Permissions
  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  


 



  


Disclaimer: VW Audi Forum is an "independant enthusiast website", administered in line with guidelines supplied by VAG in the UK, and is in no way related to any of the Worldwide Volkswagen,Audi,Seat,Skoda,Bentley,Bugatti,Porsche or Lamborghini group of Companies. For official up to date information on any of there vehicles, please visit the official websites. Any comments made throughout this website, are the views of the respective poster, and in no way represent the views of the VW Audi Forum Administration, or the worldwide Volkswagen & Audi Group of companies.


VW Audi Forum do not vet and are not responsible for any information which is posted in this forum. All content is viewed and used by you at your own risk and we do not warrant the accuracy or reliability of any of the information.


Copyright: Certain "words", "phrases" and "Images" used on this website by the Administration are "Copyright" of Volkswagen GB, Volkswagen AG (Germany), Audi GB, Audi AG (Germany), Volkswagen Motorsport GB, Volkswagen Motorsport AG (Germany), Audi Motorsport AG (Germany), Volkswagen Racing GB, Bentley, Bugatti, Porsche and Lamborghini. No image can be replicated by anyone WITHOUT the relevant Companies written permission.


All trademarks and copyrights remain property of their respective owners.

No part of the VW Audi Forum website or forum may be reproduced without written permission from the site administration


PLEASE NOTE - PERSONAL ABUSE, ABUSE AGAINST THIS OR ANY OTHER WEBSITE OR ANY COMPANY WILL NOT BE TOLERATED. OFFENDERS WILL BE MODERATED OR EVEN BANNED.


This website and forum are best viewed at a minimum resolution of 1024 by 768.



  



- VW AUDI Forum - The #1 Volkswagen (VW) Group Forum - Volkswagen (VW) - Audi - Seat - Skoda - Bentley - Bugatti - Lamborghini - Porsche - Scania - MAN - Ducatti - VW Audi Forum -


- www.vwaudiforum.co.uk - www.vwaudiforum.co.uk -