Notices
 
 

  

  • VW Audi Forum - The # 1 Volkswagen (VW) Group Forum

    VW Audi Forum - The #1 Volkswagen (VW) Forum Dedicated to the whole Volkswagen (VW) Group

    VW Audi Forum - The #1 Volkswagen (VW) Forum Dedicated to the whole Volkswagen (VW) Group of vehicles including Volkswagen (VW), Audi, Seat, Skoda, Bentley, Bugatti, Lamborghini, Porsche Motor vehicles, Scania and MAN Truck & Bus and Ducati Motorcycles.

    Topics covered include Volkswagen (VW) Group news & reviews, owners gallery, advice and general information on everything related to the Volkswagen group of vehicles

    Including owners and enthusiats of Volkswagen (VW), Audi, Seat, Skoda, Bentley, Lamborghini, Porsche Motor vehicles, Scania and MAN Truck & Bus and Ducati Motorcycles.

     
  • The driving force behind the Flying Spur V8: Engine facts and figures




    • 4.0-litre, twin-turbocharged V8 develops 135+ bhp per litre
    • Twin-scroll turbochargers mounted centrally in the V provide rapid response and maximum torque of 770 Nm, available from 2000 rpm
    • Turbines operate at a peak temperature of 950°C – as hot as lava
    • Proximity of catalytic convertors to turbos reduces cold start emissions
    • Centrally mounted fuel injectors in combustion chambers work at a pressure of 250 bar
    • Lightweight alloy pistons move at up to 20 metres per second
    • Iron alloy bore coating just 150 microns thick reduces cylinder wear to negligible level
    • Cylinder deactivation in 20 milliseconds - one tenth of a blink of an eye
    • Camshafts adjust valve timing by up to 50 degrees and can deactivate half of the cylinders
    • Grand touring range of more than 441 miles, CO2 emissions of 288g/km, and yet 0-60 mph in 4.0 seconds (0-100 km/h in 4.1 seconds)

    The new Flying Spur V8 builds on Bentley’s more than 60-year tradition of using cross-plane V8 engines. The V8-powered Flying Spur offers a characterful engine note, greater range between fuel stops and a reduction in CO2 emissions – while still offering breath-taking performance. This unlikely combination has been achieved by using the latest engineering knowledge and technology.

    The Bentley 4.0-litre V8 engine is a thoroughly modern engine, with a block cast from high strength aluminium and with twin-scroll turbochargers and primary catalytic convertors positioned in the V of the engine. Fuel injectors and spark plugs have been centralised within each combustion chamber to ensure optimal spray patterns and combustion paths, and the camshafts are variable by up to 50 degrees, with the ability to deactivate half of the cylinders when the engine is running at part load – turning it into a perfectly balanced V4.

    A Modern, Highly Efficient V8 Powertrain


    The design concept of the V8 engine has ensured the engine delivers a high level of power and torque, whilst still achieving lower emissions and the best possible efficiency.

    The compact V configuration uses a five bearing crankshaft, harnessing the power from the lightweight pistons. To minimise frictional power losses, the crankshaft also directly drives the water pump and timing chains via an intermediate shaft to improve efficiency.

    An exactly square engine, matching the stroke length to the 86 mm cylinder bore, gives the best balance between power and torque, and with the help of twin-scroll turbochargers the engine develops over 135 bhp per litre – meaning a top speed for the Flying Spur V8 of 198 mph (318 km/h).

    Turning Waste into Energy


    The V8 produces a peak power of 550 PS (542 bhp, 404 kW), with maximum torque of 770 Nm at 2000 rpm, maintaining this as a flat plateau through to 4500 rpm.

    A key feature of the twin-scroll turbochargers are the two separate, parallel flow channels in the turbine housing specifically guiding the exhaust gases to the vanes of the turbine wheel, resulting in high torque being available at low speeds. The turbochargers are located
    inside the V of the engine, minimising the distance the exhaust gases travel from the engine to the turbochargers which can operate at 176,000 rpm and generate up to 1.6 bar of boost pressure. The resulting instantaneous torque output delivers a 0-60 mph time of 4.0 secs (0-100 kph, 4.1 secs).

    Additionally, like the central turbocharger layout, another design feature of the eight-cylinder engine is the close proximity of the catalytic converters to the cylinders inside the V. This configuration allows the emissions control system to come up to its optimal operating temperature quickly. The catalytic converter heating is accelerated in the engine start phase by opening the turbocharger wastegates.

    The Perfect Mix


    Two high pressure fuel pumps driven directly by the camshafts supply the eight solenoid-driven injectors with fuel at a pressure up to 250 bar – 14 times the boiler pressure required to move a 60 tonne steam locomotive.

    The injectors are mounted centrally in the combustion chamber immediately adjacent to the spark plug, producing jets of fuel through seven nozzles into each cylinder to achieve the optimum spray pattern – and therefore air/fuel mixture - before ignition. The design of the air inlet ports supports increased tumble in the flow of the air charge entering the cylinder, with this turbulence helping to disperse fuel across the cylinder for a cleaner combustion process and reduced emissions.

    To withstand high stress and bore wear, the cylinder bores are coated with an iron alloy using an atmopheric plasma spraying process, creating a coating that is robust yet just 150 microns thick, similar to the thickness of a sheet of paper.

    Adaptable in Changing Situations


    To maximise fuel economy, the V8 engine can shut down four of its eight cylinders under light-load conditions, when torque demand is below 250 Nm and engine speed is below 3500 rpm. The change is imperceptible to the occupants – with deactivation times of around 20 milliseconds (a tenth of the time it takes to blink).

    The engine uses a two-stage sliding cam system which switches off cylinders two, three, five and eight as necessary via the intake and exhaust valves. The result is a fuel consumption benefit to the customer of up to 30 per cent depending on engine load and speed, which means increased range, lower environmental impact and longer driving between fuel stops.

    Beyond the Driving Force


    The new Flying Spur V8 has been engineered to deliver driver-focused ability, whilst offering passengers the refinement, comfort and technology expected from a grand limousine.

    The Flying Spur range is purposeful yet elegant with classic Bentley design, best-in-class execution, and authentic materials. The new Flying Spur V8 not only has contemporary engine technology, but also includes the latest driver assistance and infotainment systems for enhanced safety, security and relaxation on every journey.
    This article was originally published in forum thread: The driving force behind the Flying Spur V8: Engine facts and figures started by stuart View original post
  • VW Audi Forum Insurance


    If you need new insurance or your renewal is due, and you are looking for a good deal then please try the
    VW Audi Forum Insurance Scheme with Chris Knott Insurance

     
  • Recent Forum Posts

    TdiBlacky140

    Re: Rear caliper handbrake lever not returning to stop bar

    I have a bit of experience doing brakes all right, but I've learned the hard way regarding making sure the pads/caliper is a tight fit before fitting

    TdiBlacky140 Today, 02:02 AM Go to last post
    willdudeuk

    Re: Rear caliper handbrake lever not returning to stop bar

    @TdiBlacky140 great write up!! I do remember following the workshop manual procedure for this but I think I didn’t wind the piston out far enough like

    willdudeuk Today, 01:12 AM Go to last post
    richiet90

    1.6 alz coolant bleed screw on metal pipe snapped

    My b6 1.6 alz coolant bleed screw is snapped off and leaking, it was a plastic one. Will i have to replace whole metal pipe or can a new screw be bought

    richiet90 Today, 12:57 AM Go to last post
    michaelm713

    Re: Golf Mk8 - eSIM Losing Connection to VW Servers

    Interesting...mine was disconnected since the 5th February and it finally connected back up on Sunday 21st...shortly after I logged a ticket with WeConnect...

    michaelm713 Today, 12:48 AM Go to last post
    Handydave

    Re: Intermittant fault

    Looks hopeful. Let us know how you get on.

    Handydave Today, 12:17 AM Go to last post
    BMurr

    Gearbox and Rear Diff Oil Good forever?

    Manual 1.9tdi 6spd OX1 gearbox here with quattro rear diff and over 200,000 miles on the original drivetrain oils. No indication anywhere as to wether

    BMurr Today, 12:11 AM Go to last post
    TdiBlacky140

    Re: Rear caliper handbrake lever not returning to stop bar

    @willdudeuk - feel free to hijack, it's all relevant.

    If you fitted new calipers and the handbrake is still not holding properly, it's

    TdiBlacky140 Today, 12:00 AM Go to last post
    Zminaar

    Re: The National Lottery

    As usual this is scam... There is nothing in the web

    Zminaar Yesterday, 11:55 PM Go to last post
    Boneshed

    New joiner here

    Hi

    Currently looking after my aging but still reliable Touran 1T2 , had it for the past 7 years and its never missed a beat. 140,000 on

    Boneshed Yesterday, 11:49 PM Go to last post
    TdiBlacky140

    Re: Heating problems on a GT Sport

    Can you actually hear the blower motor when you turn on the setting 1 - 4? Is that the fan you're referring to or the rad fans as asked above. If the

    TdiBlacky140 Yesterday, 11:38 PM Go to last post
    BMurr

    Re: Replacement Floor Mats OEM quality

    Do they squeek when your shoes are wet?

    BMurr Yesterday, 11:25 PM Go to last post
    pdlh

    Re: Upgrading the standard B6 steering wheel to B6 MFSW

    Hi Monza,

    I'm definately interesting in getting your knowledge on this retrofit. I've a 2002 1.9tdi saloon, it had factory fitted cruise

    pdlh Yesterday, 11:15 PM Go to last post
    pdlh

    Re: Replacement Floor Mats OEM quality

    I'll be honest, I got fed up with my right heel wearing a hole in the carpet floor mat, for the second time, so I purchased the OEM rubber mats for the

    pdlh Yesterday, 11:00 PM Go to last post
    richiet90

    A4 1.6 powersteering pump noisey

    Hi all, my 1.6 alz a4 is suffering from a slight whine from the power steering pump.

    Basically it started a few month's ago and my silly

    richiet90 Yesterday, 10:39 PM Go to last post
    A8Cruiser

    Re: Audi S5 4.2l V8: Coolant temperature sensor location

    A8Cruiser Yesterday, 10:36 PM Go to last post
     
  • Recent Blog Posts

    RyanVolk

    VWl Van Servicing Manchester

    “I would advise anyone to completely dismiss VW Manchester van centre and go for Volksmaster, they are just better all round and totally honest with you unlike VW Manchester”

    Andy Carson
    ...

    RyanVolk 15-02-2021 05:43 PM
    RyanVolk

    Can you dance?

    [FONT=Verdana]Can you dance?

    https://www.youtube.com/embed/NDIzXL2qgvA

    [URL="https://www.volksmasterltd.co.uk"]https://www.volksmasterltd.co.uk...

    RyanVolk 15-02-2021 05:36 PM
     
  • Google Ads - One

     
  • Google Ads - Two

     
  • Google Ads - Three

     


 



  


Disclaimer: VW Audi Forum is an "independant enthusiast website", administered in line with guidelines supplied by VAG in the UK, and is in no way related to any of the Worldwide Volkswagen,Audi,Seat,Skoda,Bentley,Bugatti,Porsche or Lamborghini group of Companies. For official up to date information on any of there vehicles, please visit the official websites. Any comments made throughout this website, are the views of the respective poster, and in no way represent the views of the VW Audi Forum Administration, or the worldwide Volkswagen & Audi Group of companies.


VW Audi Forum do not vet and are not responsible for any information which is posted in this forum. All content is viewed and used by you at your own risk and we do not warrant the accuracy or reliability of any of the information.


Copyright: Certain "words", "phrases" and "Images" used on this website by the Administration are "Copyright" of Volkswagen GB, Volkswagen AG (Germany), Audi GB, Audi AG (Germany), Volkswagen Motorsport GB, Volkswagen Motorsport AG (Germany), Audi Motorsport AG (Germany), Volkswagen Racing GB, Bentley, Bugatti, Porsche and Lamborghini. No image can be replicated by anyone WITHOUT the relevant Companies written permission.


All trademarks and copyrights remain property of their respective owners.

No part of the VW Audi Forum website or forum may be reproduced without written permission from the site administration


PLEASE NOTE - PERSONAL ABUSE, ABUSE AGAINST THIS OR ANY OTHER WEBSITE OR ANY COMPANY WILL NOT BE TOLERATED. OFFENDERS WILL BE MODERATED OR EVEN BANNED.


This website and forum are best viewed at a minimum resolution of 1024 by 768.



  



- VW AUDI Forum - The #1 Volkswagen (VW) Group Forum - Volkswagen (VW) - Audi - Seat - Skoda - Bentley - Bugatti - Lamborghini - Porsche - Scania - MAN - Ducatti - VW Audi Forum -


- www.vwaudiforum.co.uk - www.vwaudiforum.co.uk -