PDA

View Full Version : VAG-COM readout help :)



samtass
07-03-2009, 02:03 PM
Hey all,

Iím new to the forum and now a proud owner of a VW Golf 1.8T (2001), itís quite a high millage one (120000) but canít fault it apart from the ones being read out by VAG that is heh. Please find below the fault readout from VAG, Iíve since cleared the codes from the engine area and going to give it a run in a minute just to see if me changing the BOV has cured some of the problems.


Iím posting this just for suggestions really, Iíve got a new temp sensor to add soon as my temp gauge is a bit weird (going up and down allot), and the coolant warning light coming on for a few minutes until she warms up. But other than that I have rough idling on a cold start and frequent misfiring when cold, but fine when warmed up, but after a short journey of being on the boost a bit, when I come to a standstill the revs almost cut-out and then start to pulse as if Iím revving at idle. So anyway thanks in advance http://www.vwvortex.com/vwbb/smile.gif.


================================================== ============================
VAG-COM Version: Release 409.1

Chassis Type: 1J - VW G/J/B Mk4
Scan: 01,02,03,08,16,15,17,19,22,35,46,56

-------------------------------------------------------------------------------
Address 01: Engine
Controller: 06A 906 032 DR
Component: 1.8L R4/5VT 0002
Coding: 11500
Shop #: WSC 00028
4 Faults Found:
17705 - Pressure Drop between Turbo and Throttle Valve (check D.V.!)
P1297 - 35-10 - - - Intermittent
17608 - Boost Pressure Control Valve (N249): Mechanical Malfunction
P1200 - 35-10 - - - Intermittent
16486 - Mass Air Flow Sensor (G70): Signal too Low
P0102 - 35-10 - - - Intermittent
16514 - Oxygen (Lambda) Sensor B1 S1: Malfunction in Circuit
P0130 - 35-00 - -
Readiness: 0000 0000
-------------------------------------------------------------------------------
Address 03: ABS Brakes
Controller: 1C0 907 379 D
Component: ASR FRONT MK60 0103
Coding: 0021505
Shop #: WSC 00028
No fault code found.
-------------------------------------------------------------------------------
Skipping Address 15-Airbags
-------------------------------------------------------------------------------
Address 17: Instruments
Controller: 1J0 920 905 B
Component: A4-KOMBIINSTR. VDO V09
Coding: 05412
Shop #: WSC 00603
IMMO-IDENTNR: VWZ7Z0Y3008827
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway
Controller: 6N0 909 901
Component: Gateway K<->CAN 0001
Coding: 00006
Shop #: WSC 00028
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv.
Controller: 1J0 959 799 Q
Component: 4F Zentral-SG Komf. 0001
Coding: 00257
Shop #: WSC 00028
2 Faults Found:
00943 - Heated Exterior Mirror: Driver Side (Z4)
35-00 - -
00944 - Heated Exterior Mirror: Passenger Side (Z5)
35-00 - -
-------------------------------------------------------------------------------
Address 56: Radio
Controller: 1J0 035 186 D
Component: RADIO SON 0003
Coding: 01401
Shop #: WSC 00028
No fault code found.
End --------------------------------------------------------------------------------------------------
Cheers Sam T

PNS2007
07-03-2009, 07:41 PM
Can't help with your engine codes but for the mirrors see:-

http://wiki.ross-tech.com/index.php/00943

You could also look for the error codes in the ross tech site aswell

saabsalltheway!
08-03-2009, 08:02 PM
Hey all,
VW Golf 1.8T
VAG-COM Version: Release 409.1
Chassis Type: 1J - VW G/J/B Mk4
Scan: 01,02,03,08,16,15,17,19,22,35,46,56
Address 01: Engine
Controller: 06A 906 032 DR
Component: 1.8L R4/5VT 0002
Coding: 11500
Shop #: WSC 00028
4 Faults Found:
17705 - Pressure Drop between Turbo and Throttle Valve (check D.V.!)
P1297 - 35-10 - - - Intermittent
17608 - Boost Pressure Control Valve (N249): Mechanical Malfunction
P1200 - 35-10 - - - Intermittent
16486 - Mass Air Flow Sensor (G70): Signal too Low
P0102 - 35-10 - - - Intermittent
16514 - Oxygen (Lambda) Sensor B1 S1: Malfunction in Circuit
P0130 - 35-00 - -
Readiness: 0000 0000
Cheers Sam T

http://wiki.ross-tech.com/index.php/16486/P0102/000258
http://wiki.ross-tech.com/index.php/16514/P0130/000304
http://wiki.ross-tech.com/index.php/17608/P1200/004608
http://wiki.ross-tech.com/index.php/17705

ive also looked at other info and it sugests possible air leaks
hth paul

Crasher
08-03-2009, 08:13 PM
Remove and clean your throttle body and reset it in Basic Settings 04, Main Group 060. Fit a new Air Mass Meter and lambda sensor before the catalyst.

samtass
11-03-2009, 08:30 AM
Cheers guys, i cleared the codes and put on a recirc valve instead of my dump valve and it seems i only have the boost pressure to worry about now, might clean the throttle anyway just to be sure, does anyone know how to check for pressure leaks, i know that there are guides on here but i'm a bit blond so i need pics :).

Thanks again..

Crasher
11-03-2009, 02:02 PM
The only accurate way to check for charge air system leaks is with the VAG charge air system tester, mine cost me over £400 with all the adapters.