PDA

View Full Version : Question 2011/12 Polo - help finding switched 12V near HU please



l33boy
26-09-2012, 01:47 PM
OK so I've found the 12V ignition switched power socket/cigarette lighter fuse and used a piggyback tap to get a switched 12V for the bluetooth kit.

What I want to contribute here is a FUSE BOX layout so that anyone else can use it as reference.
I got the data from another site but the picture was for a Left/hand drive so I've labelled up the UK R/H drive below:
18110
PDF of fuse box attached

Fuse box:

Fuse 1, 5A
Control unit in dash panel insert
ABS control unit
Mobile telephone operating electronics control unit

Fuse 2, 10A
Steering column combination switch
On-board supply control unit
Rear window wiper motor
Windscreen and rear window washer pump

Fuse 3, 5A
Fuel pump relay
Engine control unit
Fuel supply relay
Fuel pump control unit
Control unit for structure-borne sound

Fuse 4, 2A
Steering column combination switch

Fuse 5
Not used

Fuse 6, 5A
Control unit in dash panel insert

Fuse 7, 5A
Headlight range control regulator
Number plate left light
Number plate right light
On-board supply control unit

Fuse 8, 10A
Injector, cylinder 1
Injector, cylinder 2
Injector, cylinder 3
Injector, cylinder 4
Lambda probe heater
Lambda probe 1 heater after catalytic converter
Activated charcoal filter system solenoid valve

Fuse 9, 5A
7.5A TCS and ESP button
Tyre pressure monitor display button
Steering angle sender
ABS control unit
Stop/start system button
Data bus diagnostic interface

Fuse 10 on fuse holder 5A
Cruise control system switch
Steering column combination switch
Brake light switch
Clutch pedal switch
On-board supply control unit

Fuse 11, 10A
5A, Headlight range control regulator
Left headlight range control motor
Right headlight range control motor
Cruise control system switch
On-board supply control unit
Cornering light and headlight range control unit

Fuse 12, 5A
Mirror adjustment switch

Fuse 13, 5
Mechatronic unit for dual clutch gearbox
Selector lever

Fuse 14, 5A
Airbag control unit
Front passenger side airbag deactivated warning lamp

Fuse 15, 5A
Left washer jet heater element
Right washer jet heater element

Fuse 16, 5A
Parking aid control unit

Fuse 17
Not used

Fuse 18, 5A
Rear fog light cut-out contact switch
Control unit in dash panel insert
Rear left fog light bulb
On-board supply control unit

Fuse 19, 5A
On-board supply control unit

Fuse 20, 5A
Steering angle sender
Control unit in dash panel insert
Fuel supply relay
Terminal 30 voltage supply relay
Low heat output relay
High heat output relay

Fuse 21, 10A
On-board supply control unit

Fuse 22, 5A
Diagnostic connection
Climatronic control unit
Air conditioning system control unit
Mobile telephone operating electronics control unit
Ignition key withdrawal lock solenoid

Fuse 23, 5A
Selector lever
Rain sensor
On-board supply control unit
Engine control unit
Data bus diagnostic interface

Fuse 24, 5A - On-board supply control unit
Driver side heated exterior mirror
Front passenger side heated exterior mirror

Fuse 25, 5A
High pressure sender
Heater control unit
Radiator fan control unit
Air conditioning system control unit
Trailer detector control unit
Diagnostic connection
Humidity sender
Radiator fan control unit
Voltage stabiliser
Voltage stabiliser 2

Fuse 26, 7.5A
Air mass meter
Oil level and oil temperature sender
Power steering control unit
Heater element for crankcase breather
Starter relay 1
Starter relay 2

Fuse 27, 7.5A
Reversing light switch

Fuse 28, 10A
Lambda probe
Lambda probe after catalytic converter
Lambda probe heater
Lambda probe 1 heater after catalytic converter

Fuse 29, 10A
Fuel pressure regulating valve
Fuel metering valve

Fuse 30, 10A
Charge pressure control solenoid valve
Activated charcoal filter system solenoid valve 1
Exhaust gas recirculation cooler change-over valve
Coolant circulation pump 2
Heater element relay

Fuse 31, 10A
5A Sender for fuel gauge (CMAA engine only)
Automatic glow period control unit
Fuel supply relay
Additional coolant pump relay
Injector, cylinder 1
Injector, cylinder 2
Injector, cylinder 3
Injector, cylinder 4

Fuse 32, 10A/15A/20A or 30A
Fuel gauge sender
Fuel system pressurisation pump
Engine control unit

Fuse 33, 5A
Clutch position sender
Brake light switch

Fuse 34, 15A
Control unit in dash panel insert
Left main beam bulb
Right main beam bulb On-board supply control unit
Left gas discharge light control unit
Right gas discharge light control unit

Fuse 35, 15A or 20A
Engine control unit
Fuel supply relay

Fuse 36, 7.5A
Right main beam bulb

Fuse 37, 25A
Heated driver seat regulator
Heated front passenger seat regulator
Heated front seats control unit

Fuse 38, 30A
Mechatronic unit for dual clutch gearbox

Fuse 39 10or 15A
Right dipped beam bulb

Fuse 40 30A
Fresh air blower switch
Fresh air blower control unit

Fuse 41, 10A
Rear window wiper motor

Fuse 42, 15A
Cigarette lighter
12 V socket

Fuse 43, 15A
On-board supply control unit

Fuse 44, 5A
Anti-theft alarm ultrasonic sensor
Alarm horn

Fuse 45, 15A
Control unit with display for radio and navigation system
Multimedia control unit
Radio
Voltage stabiliser

Fuse 46, 20A
Headlight washer system relay
On-board supply control unit

Fuse 47, 20A
On-board supply control unit
Windscreen wiper motor

Fuse 48, 25A
On-board supply control unit

Fuse 49, 30A
Sliding sunroof adjustment control unit

Fuse 49, 15A
Fuel pump relay
Fuel supply relay

Fuse 50, 25A
Driver door control unit

Fuse 51, 25A
Front passenger door control unit

Fuse 52, 30A
Rear left door control unit
Rear right door control unit

Fuse 53, 30A
On-board supply control unit

Fuse 54, 15A
Left fog light bulb
Right fog light bulb

Fuse 55, 15A
Ignition coil 1 with output stage
Ignition coil 2 with output stage
Ignition coil 3 with output stage
Ignition coil 4 with output stage

Fuse 56, 15A - NOT PRESENT ON MY 2012 POLO - HOW DO YOU SWITCH THEM OFF!!!!!!!!:mad:
Left day driving light bulb
Right day driving light bulb

Fuse 57, 15A
On-board supply control unit

Fuse 58, 20A
Brake servo vacuum pump

Fuse 59, 10/15A
Left dipped beam bulb

Fuse 60, 15A
Control unit with display for radio and navigation system

tanstair
10-11-2014, 03:22 PM
Awesome, thanks for this. thumbs up A+++++

itavaltalainen
10-11-2014, 06:51 PM
OK so I've found the 12V ignition switched power socket/cigarette lighter fuse and used a piggyback tap to get a switched 12V for the bluetooth kit.

Fuse 56, 15A - NOT PRESENT ON MY 2012 POLO - HOW DO YOU SWITCH THEM OFF!!!!!!!!:mad:
Left day driving light bulb
Right day driving light bulb


You're not actually meant to switch them off... legal requirement as it's part of type approval of that car.
you can code it to be off with vcds thou

tanstair
10-11-2014, 09:35 PM
I have read alot about this headlight switching off issue, I'm also not a big fan of the headlight being constantly on even if it is at a lower power rating, I much prefer the DRL's to do that job from the fog light position, just a bit of a struggle without a vcds, and the fact that VW doesn't like changing it either.
I may be forced to ticker my own solution :)