PDA

View Full Version : Help please - electrical woes after towbar fitting



dstanley
20-02-2011, 12:22 PM
Can somebody help.:1zhelp:

I have fitted a towbar to my A8 (Westfalia removable and dedicated wiring). It wasn`t too difficult and all went fine until I reconnected the battery and found that much of the electrics now don`t work.
I haven`t re-coded it for the towbar yet as I am assuming that the problems I have won`t be fixed by this.

Car is 2007 D3 A8 3.0TDI. I have run Auto-scan with my newly bought VCDS (below)

I am thinking that the Central Convenience module is probably damaged but is there anything else that may need replacing?.

I thought the rear lights on the car not working could be because as it had not been recoded for the towbar so to check I reversed all the changes with the wiring but still no rear lights.

Any help would be much appreciated.






Sunday,20,February,2011,10:22:16:20561
VCDS Version: Release 10.6.3
Data version: 20101206



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 4E0
Scan: 01 02 03 05 06 07 08 09 0E 15 16 17 18 19 1E 25 34 36 37 38
42 46 47 4F 52 53 55 56 61 62 67 72 76 77

VIN: WAUZZZ4EX7N017843 Mileage: 108760km/67580miles

00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: Malfunction 0010
05-Acc/Start Auth. -- Status: Malfunction 0010
06-Seat Mem. Pass -- Status: Malfunction 0010
07-Control Head -- Status: Malfunction 0010
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
0E-Media Player 1 -- Status: Sporadic communication error 1000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
18-Aux. Heat -- Status: Malfunction 0010
19-CAN Gateway -- Status: Malfunction 0010
1E-Media Player 2 -- Status: Malfunction 0010
25-Immobilizer -- Status: Malfunction 0010
34-Level Control -- Status: Malfunction 0010
36-Seat Mem. Drvr -- Status: Malfunction 0010
37-Navigation -- Status: OK 0000
38-Roof Electronics -- Status: Malfunction 0010
42-Door Elect, Driver -- Status: Malfunction 0010
46-Central Conv. -- Status: Cannot be reached 1100
47-Sound System -- Status: OK 0000
4F-Centr. Electr. II -- Status: OK 0000
52-Door Elect, Pass. -- Status: Malfunction 0010
53-Parking Brake -- Status: Malfunction 0010
55-Xenon Range -- Status: OK 0000
56-Radio -- Status: OK 0000
61-Battery Regul. -- Status: Malfunction 0010
62-Door, Rear Left -- Status: Malfunction 0010
67-Voice Control -- Status: OK 0000
72-Door, Rear Right -- Status: Malfunction 0010
76-Park Assist -- Status: Malfunction 0010
77-Telephone -- Status: Malfunction 0010

-------------------------------------------------------------------------------
Address 01: Engine Labels: Redir Fail!
Part No SW: 4E0 910 402 E HW: 4E0 907 401 D
Component: 3.0L V6TDI G000AG 0020
Revision: --H04--- Serial number: AUX3Z0G1316693
Coding: 0011973
Shop #: WSC 02313 785 00200
VCID: 1E364B8AB031

3 Faults Found:
006256 - Transmission Mount Valve 1 (N262): Open Circuit
P1870 - 001 - Upper Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100001
Fault Priority: 0
Fault Frequency: 81
Mileage: 105965 km
Time Indication: 0
Date: 2011.01.12
Time: 17:27:34

Freeze Frame:
RPM: 756 /min
Torque: 97.5 Nm
Speed: 0.0 km/h
Duty Cycle: 1.0 %
Voltage: 13.91 V
Bin. Bits: 00101011
Torque: 202.8 Nm

005715 - Please check DTC Memory of ABS Controller
P1653 - 002 - Lower Limit Exceeded
Freeze Frame:
Fault Status: 01100010
Fault Priority: 0
Fault Frequency: 21
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:09:58

Freeze Frame:
RPM: 0 /min
Torque: 0.0 Nm
Speed: 0.0 km/h
Duty Cycle: 1.0 %
Voltage: 10.49 V
Bin. Bits: 00001000
Torque: 117.0 Nm

053248 - No Communication with Comfort System Control Module (J393)
U1000 - 001 - Upper Limit Exceeded
Freeze Frame:
Fault Status: 01100001
Fault Priority: 0
Fault Frequency: 1
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:04:51

Freeze Frame:
RPM: 924 /min
Torque: 144.3 Nm
Speed: 0.0 km/h
Duty Cycle: 1.0 %
Voltage: 13.45 V
Bin. Bits: 00001000
Torque: 284.7 Nm

Readiness: 0 0 0 0 0

-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 09L-927-760.lbl
Part No SW: 4E1 910 156 Q HW: 09L 927 156 A
Component: AG6 09L 3,0 TDI RdW 0020
Revision: --H01--- Serial number: 4297800
Coding: 0000001
Shop #: WSC 02313 785 00200
VCID: 316C8036D1AF

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 4E0-910-517.lbl
Part No SW: 4E0 910 517 B HW: 4E0 614 517 BC
Component: ESP 5.7 allrad H46 0510
Coding: 0008357
Shop #: WSC 02313 000 00000
VCID: 224E7F7A8449

1 Fault Found:
01826 - Sensor for Steering Angle (G85); Supply Voltage Terminal 30
000 - -

-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. Labels: 4E0-910-131.lbl
Part No SW: 4E0 910 131 HW: 4E0 909 131 K
Component: FBS AUDID3 H10 0190
Revision: 01904910 Serial number: AUX3Z0G1316693
Coding: 0412672
Shop #: WSC 02311 785 00200
VCID: D8BA9D921295

Part No: XXXXXXXXXXX
Component: ELV XXXX

5 Faults Found:
00190 - Driver's Door Handle Touch Sensor (G415)
007 - Short to Ground
Freeze Frame:
Fault Status: 01100111
Fault Priority: 3
Fault Frequency: 0
Reset counter: 38
Mileage: 106752 km
Time Indication: 0
Date: 2011.01.17
Time: 07:57:56

00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 2
Fault Frequency: 8
Reset counter: 149
Mileage: 108512 km
Time Indication: 0
Date: 2011.02.03
Time: 06:20:48

00181 - Access/Start Authorization Antenna (in Rear bumper) (R136)
011 - Open Circuit - Intermittent
Freeze Frame:
Fault Status: 00101011
Fault Priority: 4
Fault Frequency: 0
Reset counter: 145
Mileage: 108736 km
Time Indication: 0
Date: 2011.02.12
Time: 18:47:58

01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 3
Fault Frequency: 14
Reset counter: 109
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:00:00

00526 - Brake Light Switch-F
008 - Implausible Signal
Freeze Frame:
Fault Status: 01101000
Fault Priority: 3
Fault Frequency: 5
Reset counter: 109
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:11:44


-------------------------------------------------------------------------------
Address 06: Seat Mem. Pass Labels: None
Part No SW: 4E0 910 760 D HW: 4E0 959 760 B
Component: Sitzmemory BFS H02 0010
Revision: 00000000 Serial number: 5DS 008 795-03
Coding: 4063328
Shop #: WSC 02313 785 00200
VCID: 244279629E5D

1 Fault Found:
01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 6
Fault Frequency: 4
Reset counter: 109
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:00:01


-------------------------------------------------------------------------------
Address 07: Control Head Labels: 4E0-910-7xx-07.lbl
Part No SW: 4E0 910 769 HW: 4E0 035 729
Component: Interfacebox H43 3450
Revision: 00000000 Serial number: 343BQ077586711
Coding: 0000002
Shop #: WSC 02313 785 00200
VCID: E9DCA856B9FF

Part No: 4E0 910 611
Component: E0380 BedienteilH01 0040

1 Fault Found:
01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 5
Fault Frequency: 1
Reset counter: 109
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:00:44


-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: None
Part No SW: 4E0 910 043 B HW: 4E0 820 043 G
Component: KLIMAAUTOMAT 017 0450
Revision: 00000032 Serial number: 00000000115664
Coding: 0018433
Shop #: WSC 02311 785 00200
VCID: 1C324182A62D

2 Faults Found:
01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 5
Fault Frequency: 1
Reset counter: 109
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:05:38

Freeze Frame:
ON

01206 - Signal for Duration of Ignition Off Time
014 - Defective
Freeze Frame:
Fault Status: 01100100
Fault Priority: 5
Fault Frequency: 1
Reset counter: 109
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:05:38


-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 4E0-910-279.lbl
Part No SW: 4E0 910 279 Q HW: 4E0 907 279 Q
Component: ILM Fahrer H15 0230
Coding: 0143121
Shop #: WSC 02313 785 00200
VCID: 3666B32A38C1

Part No: 4E2 910 113 C
Component: Wischer WWS D3 H60 0440
Coding: 00000037
Shop #: WSC 02313

Part No: 4E0 910 557 A
Component: REGENLICHTSENSORH13 0090
Coding: 00139548
Shop #: WSC 02313

2 Faults Found:
00908 - Control Module for Wiper Motor
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 1
Fault Frequency: 5
Reset counter: 149
Mileage: 0 km
Time Indication: 0

01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 5
Reset counter: 109
Mileage: 0 km
Time Indication: 0


-------------------------------------------------------------------------------
Address 0E: Media Player 1 (R192) Labels: 4E0-035-785.lbl
Part No SW: 4E0 035 785 HW: 4E0 035 785
Component: SG ext.Player H09 0170
Revision: 00000000
VCID: E5C4A46655E7

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags Labels: 4E0-910-655-94.lbl
Part No SW: 4E0 910 655 D HW: 4E0 959 655 H
Component: Airbag 9.41 H14 4210
Revision: 91H14421 Serial number: 0037P0G08TUW
Coding: 0431707
Shop #: WSC 02313 785 00200
VCID: 27586E6EEF6B

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 4E0-910-549.lbl
Part No SW: 4E0 910 549 HW: 4E0 953 549
Component: Lenksäulenmodul H14 0040
Coding: 0112141
Shop #: WSC 02311 785 00200
VCID: E5C4A46655E7

Part No: XXXXXXXXXXX
Component: Lenkradmodul H07 0090

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments Labels: 4E0-910-xxx-17.lbl
Part No SW: 4E0 910 951 B HW: 4E0 920 951 B
Component: KOMBIINSTR. VDO H82 0530
Revision: D05 Serial number: AUDID3G2000870
Coding: 0000413
Shop #: WSC 00999 444 64523
VCID: 244279629E5D

No fault code found.

-------------------------------------------------------------------------------
Address 18: Aux. Heat Labels: None
Part No SW: 4E0 910 105 A HW: 4E0 815 069 G
Component: Heizgeraet H08 0140
Revision: 0000000C Serial number: 00000009013887
Coding: 0000001
Shop #: WSC 00000 000 00000
VCID: 1A3E479AAC19

1 Fault Found:
01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication

-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 4E0-910-468.lbl
Part No SW: 4E0 910 468 B HW: 4E0 907 468 E
Component: Gateway H11 0090
Revision: 11 Serial number: 20003071298031
Coding: FCFE7BDE3B7104
Shop #: WSC 02313 785 00200
VCID: 27586E6EEF6B

3 Faults Found:
02076 - Media Player Position 1 (R118)
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 3
Fault Frequency: 6
Reset counter: 143
Mileage: 108294 km
Time Indication: 0
Date: 2011.01.27
Time: 19:24:57

01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 28
Reset counter: 109
Mileage: 0 km
Time Indication: 0
Date: 2011.02.18
Time: 00:00:00

01044 - Control Module Incorrectly Coded
000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 1
Fault Frequency: 9
Reset counter: 149
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:04:47


-------------------------------------------------------------------------------
Address 1E: Media Player 2 Labels: 4E0-910-111.lbl
Part No SW: 4E0 910 110 C HW: 4E0 035 110 A
Component: MP3-Changer H44 0350
Revision: 00044000 Serial number: AUZ5ZBG3180262
Shop #: WSC 00000 000 00000
VCID: 183A5D925215

1 Fault Found:
02446 - Disk Drive Mechanical Malfunction
014 - Defective - Intermittent
Freeze Frame:
Fault Status: 00101110
Fault Priority: 7
Fault Frequency: 1
Reset counter: 149
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:00:34


-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 4E0-910-131.lbl
Part No SW: 4E0 910 131 HW: 4E0 909 131 K
Component: FBS AUDID3 H10 0190
Revision: 01904910 Serial number: AUX3Z0G1316693
Coding: 0412672
Shop #: WSC 02311 785 00200
VCID: D8BA9D921295

Part No: XXXXXXXXXXX
Component: ELV XXXX
XXXXXXXXXXX ELV XXXX

5 Faults Found:
00190 - Driver's Door Handle Touch Sensor (G415)
007 - Short to Ground
Freeze Frame:
Fault Status: 01100111
Fault Priority: 3
Fault Frequency: 0
Reset counter: 38
Mileage: 106752 km
Time Indication: 0
Date: 2011.01.17
Time: 07:57:56

00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 2
Fault Frequency: 8
Reset counter: 149
Mileage: 108512 km
Time Indication: 0
Date: 2011.02.03
Time: 06:20:48

00181 - Access/Start Authorization Antenna (in Rear bumper) (R136)
011 - Open Circuit - Intermittent
Freeze Frame:
Fault Status: 00101011
Fault Priority: 4
Fault Frequency: 0
Reset counter: 145
Mileage: 108736 km
Time Indication: 0
Date: 2011.02.12
Time: 18:47:58

01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 3
Fault Frequency: 14
Reset counter: 109
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:00:00

00526 - Brake Light Switch-F
008 - Implausible Signal
Freeze Frame:
Fault Status: 01101000
Fault Priority: 3
Fault Frequency: 5
Reset counter: 109
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:11:44


-------------------------------------------------------------------------------
Address 34: Level Control Labels: 4E0-910-553.lbl
Part No SW: 4E0 910 553 J HW: 4E0 907 553 F
Component: LUFTFDR.-CDC H06 6310
Coding: 0015510
Shop #: WSC 02313 785 00200
VCID: 2A5E975AFC79

2 Faults Found:
01398 - Signal Conductor for Central Locking; Doors Open
004 - No Signal/Communication
Freeze Frame:
Fault Status: 11100100
Fault Priority: 4
Fault Frequency: 5
Reset counter: 109
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:19:24

01598 - Drive Battery Voltage
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 4
Fault Frequency: 2
Reset counter: 149
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 13:54:34


-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr Labels: None
Part No SW: 4E0 910 760 D HW: 4E0 959 760 B
Component: Sitzmemory FS H02 0010
Revision: 00000000 Serial number: 5DS 008 795-03
Coding: 4063338
Shop #: WSC 02313 785 00200
VCID: 244279629E5D

1 Fault Found:
01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 6
Fault Frequency: 10
Reset counter: 109
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:00:01


-------------------------------------------------------------------------------
Address 37: Navigation Labels: 4E0-910-88x-37.lbl
Part No SW: 4E0 910 887 T HW: 4E0 919 887 L
Component: MNS ECE H48 1030
Revision: 00000000 Serial number: 364CU077644905
Shop #: WSC 00137 210 91082
VCID: 3E76AB0A10F1

No fault code found.

-------------------------------------------------------------------------------
Address 38: Roof Electronics Labels: 4E0-910-135.lbl
Part No SW: 4E0 910 135 A HW: 4E0 907 135 A
Component: Dachknoten D3 H05 0090
Serial number: 00000703600081
Coding: 0035968
Shop #: WSC 02313 785 00200
VCID: 1D344C86BD37

1 Fault Found:
01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 0
Fault Frequency: 3
Reset counter: 109
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:00:00


-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: None
Part No SW: 4E1 910 802 B HW: 4E2 959 802 D
Component: Türsteuer.FS BRM005 0180
Coding: 0028462
Shop #: WSC 02313 785 00200
VCID: 204A75728A45

1 Fault Found:
01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 4
Fault Frequency: 0
Reset counter: 109
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:00:10


-------------------------------------------------------------------------------
Address 46: Central Conv.
Cannot be reached

-------------------------------------------------------------------------------
Address 47: Sound System Labels: 4E0-910-223.lbl
Part No SW: 4E0 910 223 Q HW: 4E0 035 223 G
Component: DSP-High D3 H03 0110
Revision: PROD_01 Serial number: 00000000005204
Coding: 0000023
Shop #: WSC 02313 785 00200
VCID: 2B50925EF383

No fault code found.

-------------------------------------------------------------------------------
Address 4F: Centr. Electr. II Labels: None
Part No SW: 4E0 910 280 A HW: 4E0 907 280 A
Component: ILM Beifahrer H11 0070
Revision: Serial number: 00000000107455
Coding: 0010101
Shop #: WSC 02313 785 00200
VCID: 1E364B8AB031

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: None
Part No SW: 4E1 910 802 B HW: 4E2 959 801 D
Component: Türsteuer.BF BRM005 0180
Coding: 0028462
Shop #: WSC 02313 785 00200
VCID: 204A75728A45

1 Fault Found:
01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 4
Fault Frequency: 0
Reset counter: 109
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:00:10


-------------------------------------------------------------------------------
Address 53: Parking Brake Labels: 4E0-910-801.lbl
Part No SW: 4E0 910 801 D HW: 4E0 907 801 B
Component: EPB A4EC0230 H03 0230
Revision: --H03---
Coding: 0000221
Shop #: WSC 02313 785 00200
VCID: 204A75728A45

1 Fault Found:
02596 - Rear Brake Pads Worn
008 - Implausible Signal
Freeze Frame:
Fault Status: 01111000
Fault Priority: 6
Fault Frequency: 2
Reset counter: 116
Time Indication: 0

Freeze Frame:
Voltage: 7.76 V
Count: 61


-------------------------------------------------------------------------------
Address 55: Xenon Range Labels: 8P0-907-357.lbl
Part No: 8P0 907 357 F
Component: Dynamische LWR H02 0010
Revision: 00000001 Serial number:
Coding: 0000006
Shop #: WSC 02313 785 00200
VCID: 3D74AC061DF7

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio Labels: 4E0-910-541.lbl
Part No SW: 4E0 910 541 Q HW: 4E0 035 541 S
Component: TUNER EU/US/RDW H42 0620
Revision: 00000000 Serial number: 396CS077561225
Coding: 0000001
Shop #: WSC 02313 785 00200
VCID: 2E569B4AC091

No fault code found.

-------------------------------------------------------------------------------
Address 61: Battery Regul. Labels: 4E0-910-181.lbl
Part No SW: 4E0 910 181 C HW: 4E0 915 181 C
Component: J0644 BEM H12 0550
Revision: 00000000 Serial number: 00000000001685
Shop #: WSC 00137 210 91082
VCID: 204A75728A45

Part No: 4E0 915 105 A
Component: von VA0 2702280327
Coding: 344530393135313035412056413032373032323830333237
Shop #: WSC 00000 128 00289

5 Faults Found:
02272 - Quiescent Current Stage 1
000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 7
Fault Frequency: 22
Mileage: 65848 km
Time Indication: 0
Date: 2009.12.24
Time: 21:53:33

02273 - Quiescent Current Stage 2
000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 7
Fault Frequency: 10
Mileage: 65848 km
Time Indication: 0
Date: 2009.12.24
Time: 21:57:01

02276 - Quiescent Current Stage 5
000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 7
Fault Frequency: 9
Mileage: 78086 km
Time Indication: 0
Date: 2010.04.22
Time: 12:10:39

02277 - Quiescent Current Stage 6
000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 7
Fault Frequency: 4
Mileage: 78086 km
Time Indication: 0
Date: 2010.04.22
Time: 00:44:56

02274 - Quiescent Current Stage 3
000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 7
Fault Frequency: 3
Mileage: 108569 km
Time Indication: 0
Date: 2011.02.10
Time: 22:58:44


-------------------------------------------------------------------------------
Address 62: Door, Rear Left Labels: 4E0-910-802.lbl
Part No SW: 4E0 910 802 A HW: 4E0 959 801 D
Component: Türsteuer.HL BRM005 0180
Coding: 0028462
Shop #: WSC 02313 785 00200
VCID: 1E364B8AB031

1 Fault Found:
01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 4
Fault Frequency: 0
Reset counter: 109
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:00:10


-------------------------------------------------------------------------------
Address 67: Voice Control Labels: 4E0-910-75x-67.lbl
Part No SW: 4E0 910 754 S HW: 4E0 035 753 A
Component: SDS 3502 UK H45 0630
Revision: 00000000 Serial number: 00000702260074
Shop #: WSC 12336 024 394758
VCID: 3666B32A38C1

No fault code found.

-------------------------------------------------------------------------------
Address 72: Door, Rear Right Labels: 4E0-910-802.lbl
Part No SW: 4E0 910 802 A HW: 4E0 959 802 D
Component: Türsteuer.HR BRM005 0180
Coding: 0028462
Shop #: WSC 02313 785 00200
VCID: 1E364B8AB031

1 Fault Found:
01330 - Central Control Module for Central Convenience (J393)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 4
Fault Frequency: 0
Reset counter: 109
Mileage: 108768 km
Time Indication: 0
Date: 2011.02.18
Time: 00:00:10


-------------------------------------------------------------------------------
Address 76: Park Assist Labels: 4E0-910-283.lbl
Part No SW: 4E0 910 283 C HW: 4E0 919 283 C
Component: Parkhilfe 8-Kan H12 0040
Revision: 00H12000 Serial number: 08720705200344
Coding: 0201008
Shop #: WSC 02313 785 00200
VCID: 23407A7E9B53

1 Fault Found:
02070 - Rear Parking Aid Sensors
011 - Open Circuit - Intermittent
Freeze Frame:
Fault Status: 00101011
Fault Priority: 3
Fault Frequency: 1
Reset counter: 145
Mileage: 108740 km
Time Indication: 0
Date: 2011.02.12
Time: 18:51:17


-------------------------------------------------------------------------------
Address 77: Telephone Labels: 4F1-910-336.lbl
Part No SW: 4F1 910 336 A HW: 4F1 862 335
Component: BTA H09 0710
Revision: 00H09000 Serial number: 00000007524576
Coding: 1060001
Shop #: WSC 02313 785 00200
VCID: 224E7F7A8449

1 Fault Found:
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 7
Fault Frequency: 1
Reset counter: 149
Mileage: 78086 km
Time Indication: 0
Date: 2010.04.22
Time: 13:16:26


End ---------------------------------------------------------------------

phil miller
20-02-2011, 12:31 PM
sorry if i sound stupid did you use a canbus wiring connector? ive used and fitted these many times at work and have never had a problem afterwards, if you disconnect the tow bar wiring does everything work as it should?

a8 tech
20-02-2011, 12:33 PM
you have battery management cut of stages set so recharge the battery above 12.5 volts then clear down all the faults

encode the tow bar into the network and recheck before you do anything

encode each control unit to add trailer electrics and type, some control units may be not be fitted ie acc adaptive cruise control but address 19 first then 01,34,45 and 76
01 Engine control unit
13 Distance control ACC
19 Diagnosis interface for data bus
34 Level control
45 Brake electronics ESP
76 Park distance control

after you have coded clear the codes and cycle the ignition then connect the trailer and check don't forget the charge circuit for the fridge is not present as standard so you need the extra circuit and relay to switch the the feed to the craven

dstanley
22-02-2011, 01:03 AM
Progress Update - Still a bit of help needed please :1zhelp:

I decided to follow a8 tech`s advice (thanks a lot for giving me the confidence to have a go rather than just call the dealer).

I checked the battery and that was reading 12.2v OK I thought, but before charging it I wanted to re-wire in the towbar electrics (as I had previously undone it all to see if this fixed my problems). As I removed the battery the thin red/white wire to the battery positive connector broke away from it`s ring connector. So first I fixed this and then re-wired up the towbar electrics exactly (I think) as before and re-connected the battery.

Hey presto all the things that had stopped working (central locking, auto boot, lights in boot etc started working again (don`t know if it was that little wire that had been damaged or if I did something different this time). I ran an autoscan and cleared all the faults and then started to re-coding with VCDS for the trailer settings. This is where I need a bit more help.

19 - Diagnosis interface for data bus - OK I think - ticked "[69] Trailer Installed" it changed from 11111100 to 11111101 then I clicked "Exit" then "Go for It"
01 - Engine control unit - Couldn`t work out how to do it. Under "Coding-07" it had a different screen with Software coding, Workshop code, Importer number and Equipment number - Software coding was 0011973 but no instructions on what to change popped up. Am I missing something?
34 - Level Control - OK I think - Changed from 0015510 to 0015520
45 - My 45 is "Inter. Monitor" not "ESP" !!. I couldn`t find ESP anywhere but I guess the car has it any ideas?
76 - Park Distance control - OK I think - Changed from 0201008 to 0211008

Haven`t attached the trailer yet as I want to get all the coding sorted out first.