PDA

View Full Version : NON start tdi....??



producedapples
12-08-2010, 04:38 PM
Good afternoon all, Im currently TRYING to resolve an issue on a 53 plate tourag, i have got a reg version of vagcom vcds used, with a full auto scan as reads....
Chassis Type: 7L - VW Touareg
Scan: 01 02 03 05 06 08 09 11 13 15 16 17 18 19 1C 22 29 32 34 36
37 39 3C 46 47 55 56 57 64 65 68 69 6C 6D 6E 75 76 77

VIN: WVGZZZ7LZ4D006192 Mileage: 114620km/71221miles
-------------------------------------------------------------------------------
Address 01: Engine Labels: Redir Fail!
Part No SW: 070 997 016 E HW: 028 101 125 8
Component: R5 2,5L EDC G001SG 9769
Revision: 12345678 Serial number: VWZ3Z0C1078855
Coding: 0001172
Shop #: WSC 00478 210 88567
VCID: 1C33AC84A6C3
1 Fault Found:
16687 - Cylinder 3: Misfire Detected
P0303 - 000 - - - Intermittent
Freeze Frame:
RPM: 798 /min
Torque: 144.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 14.14 V
Inj. Quantity: 2.96 mg/str
Temperature: 18.9°C
(no units): 0.0
Readiness: 0 0 0 X 1
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 7L0-907-379-MK25.lbl
Part No: 7L0 907 379 D
Component: ESP ALLRAD MK25 0108
Coding: 0004097
Shop #: WSC 00488 210 15929
VCID: 3A7F4A1C0C37
1 Fault Found:
00778 - Steering Angle Sensor (G85)
000 - -
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. Labels: 3D0-909-13x-05.lbl
Part No SW: 3D0 909 135 J HW: 5WK 470 21
Component: Kessy 6400
Coding: 0000234
Shop #: WSC 31414 000 00000
VCID: 2C537C44F663
Part No: XXXXXXXXXXX
Component: ELV XXXX
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: None
Part No: 7L6 907 040 D
Component: CLIMAtronic R/L X 2714
Coding: 0001020
Shop #: WSC 31414 000 00000
VCID: 316D6D30D141
2 Faults Found:
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
01336 - Data Bus for Comfort System
004 - No Signal/Communication - Intermittent
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 7L6-937-049.lbl
Part No: 7L6 937 049 K
Component: 2703
Coding: 0099492
Shop #: WSC 31414 000 00000
VCID: 448334E47EF3
4 Faults Found:
00967 - Left Turn Signals
014 - Defective - Intermittent
00968 - Right Turn Signals
014 - Defective - Intermittent
01517 - Control Module for Trailer/Towing Sensor (J345)
014 - Defective
00907 - Intervention load Management
000 - -
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 3D0-909-601.lbl
Part No: 3D0 909 601 D
Component: 01 Airbag 8.4E+ H07 0951
Coding: 0012337
Shop #: WSC 31414 000 00000
VCID: 244394649EB3
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 7L6-953-549.lbl
Part No: 7L6 953 549 B
Component: Lenksäulenmodul 3201
Coding: 0000031
Shop #: WSC 31414 000 00000
VCID: 3E77460C101F
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 7L6-920-xxx-17-7LA.lbl
Part No: 7L6 920 970 B
Component: KOMBIINSTRUMENT RB4 1735
Coding: 0007411
Shop #: WSC 00478 210 91483
VCID: 36675E2C382F
No fault code found.
-------------------------------------------------------------------------------
Address 18: Aux. Heat Labels: Redir Fail!
Part No: 7L6 815 071 A
Component: Standheizung E1MAC 0121
Shop #: WSC 00000 000 00000
VCID: 306B6834DA4B
3 Faults Found:
01126 - Engine Speed Signal
008 - Implausible Signal - Intermittent
00664 - Fuel gauge
002 - Lower Limit Exceeded - Intermittent
01408 - Under-Voltage Shut-Off (fixed Value)
002 - Lower Limit Exceeded - Intermittent
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 6N0-909-901-19.lbl
Part No: 6N0 909 901
Component: Gateway K<>CAN 0101
Coding: 0000006
Shop #: WSC 31414 000 00000
VCID: F0EB28349ACB
1 Fault Found:
00778 - Steering Angle Sensor (G85)
004 - No Signal/Communication - Intermittent
-------------------------------------------------------------------------------
Address 22: AWD Labels: None
Part No: 0AD 927 755 BF
Component: TRANSFERCASE 2122
Shop #: WSC 00000 000 00000
VCID: 800B78F4AA6B
No fault code found.
-------------------------------------------------------------------------------
Address 29: Left Light Labels: 3D0-909-157.lbl
Part No: 3D0 909 157
Component: EVG GDL+AutoLWR(l) X012
Coding: 0000002
Shop #: WSC 31414 000 00000
VCID: E6C74E6CA80F
No fault code found.
-------------------------------------------------------------------------------
Address 39: Right Light Labels: 3D0-909-158.lbl
Part No: 3D0 909 158
Component: EVG GDL+AutoLWR(r) X012
Coding: 0000002
Shop #: WSC 31414 000 00000
VCID: E7D94368AF05
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv. Labels: 7L0-959-933.lbl
Part No: 7L0 959 933 C
Component: JN HSG 0101
Coding: 0000065
Shop #: WSC 31414 000 00000
VCID: 3C734C040603
Part No: 7L0 959 701 E
Component: Tuersteuergeraet FS 0104
Part No: 7L0 959 702 D
Component: Tuersteuergeraet BF 0104
Part No: 7L0 959 703
Component: Tuersteuergeraet HL 0104
Part No: 7L0 959 704
Component: Tuersteuergeraet HR 0104
Part No: 7L0 907 719
Component: Neigungssensor 0020
Part No: 7L6 951 171
Component: A Innenraumsensor 0019
5 Faults Found:
00987 - Lamp for Brake Light; Left (M9)
009 - Open or Short to Ground - Intermittent
00988 - Lamp for Brake Light; Right (M10)
009 - Open or Short to Ground - Intermittent
00932 - Electric Window Motor; Drivers Side (V147)
005 - No or Incorrect Basic Setting / Adaptation - Intermittent
00915 - Window Regulator Switch; Rear Right; Driver (E55)
007 - Short to Ground - Intermittent
00930 - Locking Module for Central Locking; Rear Left (F222)
008 - Implausible Signal - Intermittent
-------------------------------------------------------------------------------
Address 56: Radio Labels: 3B7-035-1xx-56.lbl
Part No: 7L6 035 195
Component: Radio DE2 0011
Coding: 0001407
Shop #: WSC 00488 210 15929
VCID: F0EB28349ACB
1 Fault Found:
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded
-------------------------------------------------------------------------------
Address 68: Wiper Electr. Labels: None
Part No: 7L0 955 119 G
Component: Front Wiper 2416
Coding: 0000002
Shop #: WSC 31414 000 376832
VCID: 387B5014323B
No fault code found.
-------------------------------------------------------------------------------
Address 69: Trailer Labels: Redir Fail!
Part No SW: 7L0 907 383 N HW: 7L0 907 383 N
Component: J345 Anhaenger 0080
Revision: 4A008002 Serial number: 00000118035250
Coding: 0016385
Shop #: WSC 00000 000 00000
VCID: 3F893B081715
1 Fault Found:
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 3
Fault Frequency: 3
Reset counter: 40
Time Indication: 0


I see there is a missfire on cylinder 3, but the damn thing wont start....any ideas would be muchly appreciated....:beerchug:

FYI the engine turns and turns and turns.......no fire tho

dickymint
13-08-2010, 04:40 PM
I have a 2004 R5 Treg. Sorry but I can't assist with your problem except to suggest you try www.mytreg.com (http://www.mytreg.com). There are members there who may be able to advise. Let us know how you get on.

smokeygsi
14-08-2010, 10:24 AM
Check the manifold change over flap - they do stick on the R5 engine when they get gummed up with carbon etc -

Its just before the inlet manifold and just after the boost pipe if you arent sure where it is

producedapples
17-08-2010, 10:21 AM
ok thanks for that, i didnt reply as i did get it started after, took it for a run, and THOUGHT all was well, as did another auto scan after a clear of all codes, and no faults, car started fine on turn of key, so i thought was just a semi flat battery, so came back to it today after car been on trickle charge for a few days, and takes bout 45 secs of turning before it splutters into life, with a missfire. then only an italian tune up clears it.....il have a look at this flap now and keep u guys updated...:Blush:

producedapples
17-08-2010, 10:24 AM
Check the manifold change over flap - they do stick on the R5 engine when they get gummed up with carbon etc -

Its just before the inlet manifold and just after the boost pipe if you arent sure where it is

Do you mean the EGR valve?? thats whats between boost pipe and inlet manny......

If so, its clean, moves freely, and operates

smokeygsi
18-08-2010, 07:02 PM
It is part of the egr valve yeh..

When its misfiring have you checked the measured values to see which cylinder is missing?